The objectives of the present study were to assess the baking properties of composite spelt wheat–amaranth blends and to study the staling of composite breads during a six-day storage. Different forms of amaranth grains were added to spelt bread formulation: native amaranth flour and flour from popped amaranth, including their scalded and non-scalded variants. Native amaranth flour (both scalded and non-scalded) gave loaves with the highest volume and contributed to significantly softer crumb but not in comparison to the control bread. Crumb resilience did not show significant differences among the breads but there were differences in the crumb stress relaxation parameters which indicated certain influence on the crumb viscoelastic properties. During storage, all samples developed firmer and less elastic crumbs. Drying loss and staling degree significantly increased with increased storage time. The staling rate was the highest in the bread with non-scalded amaranth flours (native and flour from popped amaranth). The changes in the crumb textural and elastic properties caused by staling turned significant after six days of storage. In general, inclusion of different forms of amaranth flour did not alter the staling of breads and they exerted similar behaviour during storage.
In this study, the evaluation of the performance of two thin-film UV-C reactors (annular and Taylor–Couette) and a coiled tube system is presented using actinometry and biodosimetry methods. The iodide/iodate actinometry method was found suitable for comparison of the efficiency of UV-C dose delivery of the UV-C continuous flow systems. Inactivation kinetics of Escherichia coli ATCC 8739 in quarter-strength Ringer’s solution (absorption coefficient α254 nm ~ 0 cm–1) at various flow conditions at Reynolds numbers in the range of 26 to 3000 showed a good correlation between the different reactor types. In high UV-C absorbing liquids, the inactivation efficiency increases due to the improved radial mixing. The inactivation performance of the Taylor–Couette system correlates to the annular reactor when no rotation force is applied. The residence time distributions showed the narrowest distribution with the coiled tube system at comparable flow rates. The results indicate that, despite the laminar flow conditions, the performance of the Taylor–Couette unit becomes equal to the turbulent flow conditions of the coiled tube reactor by rotation of the inner cylinder.
A new approach to the use of high hydrostatic pressure is its combination with high and intermediate temperatures applied to obtain safe foods of high quality. The effect of high hydrostatic pressure on color, residual polyphenol oxidase and pectin methylesterase activity, and total phenolic and
In the present study, it was hypothesized that the incorporation of fatty acids is distinct among ruminant tissues and that it could be modulated by diet composition. To test this hypothesis, fatty acid composition, including conjugated linoleic acid isomers, of the most relevant beef by-products (brain, heart, kidney, liver, pancreas and tongue) from young bulls those fed distinct silage levels was assessed. Data indicated a large variation in fatty acid profile and conjugated linoleic acid composition among edible by-products. The most abundant fatty acids were C16:0 (kidney), C18:0 (heart and liver) and C18:1c9 (brain, pancreas and tongue) followed by C20:4n-6, except in brain (C22:6n-3 predominates). Brain, as shown by principal component analysis, presents a distinct fatty acid composition compared to the other beef by-products analysed. In addition, high silage diet relative to low silage diet promoted an increase of n-3 polyunsaturated fatty acid, t11,t13 and t11,c13 conjugated linoleic acid in heart, kidney, liver and pancreas. Overall, the data suggested that beef by-products had, in general, high contents of cholesterol, saturated fatty acid and trans fatty acid, as well as high levels of conjugated linoleic acid. Therefore, from a nutritional point of view they are recommended only in small amounts as part of a balanced diet.
This study aims to investigate the effect of high-pressure processing on the quality of black tiger shrimp using response surface methodology. A central composite rotatable design was applied to evaluate the effects of three processing parameters, namely pressure (300–600 MPa), temperature (30–50 ℃), and time (0–15 min), on the inactivation rate of Staphylococcus aureus and physical properties (color and texture) of shrimp and to optimize the process conditions to achieve maximum bacterial inactivation with minimal changes in quality attributes. The results revealed that the processing conditions significantly affected the studied responses and the experimental data have been adequately fitted into a second-order polynomial model with multiple regression coefficients (R2) of 0.92, 0.92, and 0.94 for the inactivation rate of S. aureus, hardness, and color changes, respectively. The optimized conditions targeting minimum six log cycle reductions of S. aureus with moderate changes in quality attributes were obtained as: pressure, 361 MPa; time, 12 min and temperature, 46 ℃. The adequacy of the model equation for predicting the optimum response values was verified effectively by the validation data.
The aim of this study was to determine the influence of different packaging materials on meat quality during cold storage. Therefore pork loins (m. longissimus thoracis et lumborum) obtained from crossbred pigs (Polish Landrance x Duroc, n = 6) were stored at 2 ℃ in modified atmosphere packs (80% O2, 20% CO2) in four types of trays, which differ in gas permeability. Physicochemical (headspace gas composition, pH, colour, drip loss, cooking loss, shear force, the basic composition and fatty acid profile) and microbiological (Salmonella spp., Escherichia coli, Enterobacteriaceae, total aerobic plates count, total psychrotrophic bacteria count, the number of lactic acid bacteria, Pseudomonas spp., the general amount of yeast and mold) parameters were monitored for up to 12 days. At the end of the storage period no differences in most physicochemical properties of pork loin due to type of packaging were found, however trays with high gas permeability had the greatest impact on total aerobic plates count and Pseudomonas spp. growth.
Alicyclobacillus acidoterrestris is one of the most spoilage-causing bacteria in fruit juices. In this paper, controlling A. acidoterrestris in apple juice by bacteriocin RC20975 was described. Twenty-one strains of A. acidoterrestris were used to investigate the activity spectrum of bacteriocin RC20975 in apple juice with the result that 16 strains were sensitive. The ratio of activity in apple juice to the activity in laboratory medium was 42%. The reduction of antimicrobial activity in apple juice might be due to problems related to its interaction with food components. Adsorption of bacteriocin RC20975 to A. acidoterrestris cells varied according to the strains and the testing conditions (pH and temperatures). In an acid environment (pH 3 and pH 5), the adsorption was higher than that of the neutral environment. Dynamic model of killing bacteria was built under the condition of different temperatures with the addition of bacteriocin. Electron microscopy examination of vegetative cells revealed substantial cell damage and bacterial lysis after bacteriocin treatment. Although the endospores could not be killed, the addition of bacteriocin RC20975 contributed to the reduction of the thermal resistance of A. acidoterrestris spores in apple juice. In sum, bacteriocin RC20975 was proved to have a good effect on killing A. acidoterrestris in apple juice.
Sponge cake is a sweet bakery product characterized by its aerated and soft crumb and by its thin-coloured crust. The aim of this work is to analyse the influence of baking conditions (natural or forced convection, steam injection, oven temperature from 140 ℃ to 180 ℃) on sponge cake quality. Both crust and crumb regions were characterized by means of colour development, water content, crust/crumb relation, crust thickness and crumb structure (in terms of porosity, crumb density and texture). Colour measurements allowed obtaining an accurate model for browning kinetics. Crumb water content remains almost constant, while considerable dehydration occurs in the crust. In general, no significant differences due to baking conditions were found in the instrumental quality analysis.
The aim of the present study was to evaluate the applicability of using protein-rich isolates from tomato seed as a sole source of nutrition for the growth of lactic acid bacteria. Unstructured mathematical and logistic models were proposed to describe growth, pH drop, lactic acid production and nutriment consumption by Lactobacillus plantarum in whole and defatted isolates in order to compare their suitability for the production of a fermented beverage. These media have considerable good quantities of nutriment that allowed the growth of L. plantarum, after which the cell numbers begin to decline. The maximum biomass was observed in defatted isolate (1.42 g L–1) followed by the whole isolate (1.24 g L–1). The lactic acid increased by about 5.5 and 6.5 times respectively in whole and defatted protein isolates. However, significant nutriment consumption occurred during the growth phase as well as stationary phase. A reduction of 61.90% and 95.88% in sugar content, as well as 21.91% and 16.93% reduction in protein content were observed respectively in whole and defatted isolates. In most cases, the proposed models adequately describe the biochemical changes taking place during fermentation and are a promising approach for the formulation of tomato seed-based functional foods.
The effect of protein addition on the rheological, thermo-mechanical and baking properties of wholegrain rice flour was investigated. Gluten, powdered eggs and soy protein concentrate were first analyzed in terms of rheological properties, alone and in admixture with rice flour. The temperature ramp tests showed clear differences in the rheological behavior of the batters supplemented with different proteins. The highest thermal stability was observed in case of soy protein samples. Frequency sweep tests indicated significant improvements of the rheological properties of rice flour supplemented with 15% gluten or soy proteins. The thermo-mechanical tests showed that, due to the high fat contents and low level of free water, the dough samples containing powdered eggs exhibited the highest stability. Addition of gluten resulted in a significant decrease of the dough development time, whereas samples with powdered eggs and soy proteins were more difficult to hydrate. The incorporation of proteins into the rice flour-based dough formulations significantly affected starch behavior by decreasing the peak consistency values. Concerning the quality of the rice flour-based breads, soy protein addition resulted in lighter crumb color and increased texture attributes, samples with gluten had better resilience and adhesiveness, whereas breads with egg protein were less brittle.
Cape gooseberry (Physalis peruviana L.) fruits are highly perishable berries that exhibit a climacteric respiratory behavior. The objective of this study was to evaluate the effect of ethylene and the ethylene action inhibitor 1-methylcyclopropene on the postharvest behavior of cape gooseberry fruits (ecotype Colombia). Fruits were treated with ethylene, in an ethephon application (1000 µL L–1), and pretreated with 1-methylcyclopropene (1 µL L–1), 1-methylcyclopropene+ethylene, and results compared with a control without application. Subsequently, the fruits were maintained at room temperature (20 ℃, 75% RH) for up to 11 days. The pretreatment of the cape gooseberry fruits with 1-methylcyclopropene delayed most of the ripening-associated parameters, with a reduction in the respiration rate and ethylene production, skin color development, total soluble solids, total carotenoid content, loss of firmness, loss of total titratable acidity and emission of volatile compounds such as ethyl octanoate, ethyl butanoate, ethyl decanoate, and hexyl decanoate. Conversely, application of ethephon accelerated most of these physiological changes and also overcame most of the effects prevented by the ethylene action inhibitor. Altogether, the results supported the idea of a climacteric-like behavior for cape gooseberry fruits and pointing out that the pretreatment with 1-methylcyclopropene may be a promising and efficient postharvest treatment to delay maturity and extend the postharvest period.
The use of pseudocereals, legumes and ancient grains for breadmaking applications is receiving particular attention since they involve nutrient dense grains with proven health-promoting attributes. Dilution up to 45% of the basic wheat flour matrix by accumulative ternary addition of teff, green pea and buckwheat flours did significantly impact both the extractability and distribution of lipid subfractions in composite flours, doughs and breads, and induced differentiated dynamics in lipid binding along breadmaking. During mixing, a preferential covalent lipid binding to the inside part of the starch granules takes place at the expenses of both accessible free lipids and lipids initially bound non-covalently to the gluten/non-gluten proteins and to the outside part of the starch granules. During fermentation and later baking a preferential lipid binding to the gluten/non-gluten proteins and to the outside and inside starch granules takes place at the expenses of both a free lipid displacement and a bound lipid translocation to new protein and starch active sites. It can be noticed that the larger the accumulation of both protein- and starch-bound lipids over fermentation and baking, the higher physic-chemical and sensory profiles, and the slower starch hydrolysis, firming and retrogradation kinetics of composite breads were obtained.
The aim of this work was to develop a new system based on impedance spectroscopy to assess the heat treatment of previously cooked chicken meat by two experiments; in the first, samples were cooked at different temperatures (from 60 to 90 ℃) until core temperature of the meat reached the water bath temperature. In the second approach, temperature was 80 ℃ and the samples were cooked for different times (from 5 to 55 min). Impedance was measured once samples had cooled. The examined processing parameters were the maximum temperature reached in thermal centre of the samples, weight loss, moisture and the integral of the temperature profile during the cooking–cooling process. The correlation between the processing parameters and impedance was studied by partial least square regressions. The models were able to predict the studied parameters. Our results are essential for developing a new system to control the technological, sensory and safety aspects of cooked meat products on the whole meat processing line.
The aim of this study was to investigate the effects of high hydrostatic pressure and thermal processing on microbiological quality, bioactive compounds, antioxidant activity, and volatile profile of mulberry juice. High hydrostatic pressure processing at 500 MPa for 10 min reduced the total viable count from 4.38 log cfu/ml to nondetectable level and completely inactivated yeasts and molds in raw mulberry juice, ensuring the microbiological safety as thermal processing at 85 ℃ for 15 min. High hydrostatic pressure processing maintained significantly (p < 0.05) higher contents of total phenolic, total flavonoid and resveratrol, and antioxidant activity of mulberry juice than thermal processing. The main volatile compounds of mulberry juice were aldehydes, alcohols, and ketones. High hydrostatic pressure processing enhanced the volatile compound concentrations of mulberry juice while thermal processing reduced them in comparison with the control. These results suggested that high hydrostatic pressure processing could be an alternative to conventional thermal processing for production of high-quality mulberry juice.
This work aimed at evaluating the effects of sous-vide cooking parameters, such as time and temperature and their interactions, on textural attributes of ‘Mondial Gala’ and ‘Granny Smith’ apple cultivars. For this, different response surface methodology-based models were developed. This methodology proved a suitable means for the assessment of changes in textural parameters and cell wall modifications during the processing of apples. ‘Mondial Gala’ fruit displayed better aptitude for the preservation of textural properties after high-temperature processing conditions and were therefore apparently more suited to sous-vide cooking than ‘Granny Smith’ apples. Pectin methylesterase activity levels in ‘Mondial Gala’ apples were enhanced at mild temperatures and pectins in this cultivar displayed a lower degree of methylation. Therefore, the establishment of calcium-mediated linkages between cell wall polymers might have been favoured in ‘Mondial Gala’ apples, thus reinforcing tissues and improving the preservation of textural attributes, in comparison to ‘Granny Smith’ samples.
The processing of sous vide chicken sausages was optimized under vacuum packaging condition and cooking at 100 ℃ for 30 min (SV30), 60 min (SV60) and 120 min (SV120) and compared with aerobically cooked control at 100 ℃ for 30 min. Sous vide processing of chicken sausages (SV30) produced higher (p < 0.05) cooking yield, Hunterlab a* values and sensory attributes without affecting proximate composition and shear force values relative to control. The sodium dodecyl sulphate-polyacrylamide gel electrophoresis and scanning electron microscopy results revealed no significant changes in protein quality and emulsion ultra-structure due to SV30 processing relative to control sausages. Sous vide processing of chicken sausages enriched with rosemary diterpene phenols retained the freshness and quality up to 120 days during storage at 4 ± 1 ℃ relative to control sausages that were spoiled on 20th day. Lipid oxidation and microbial growth remained below the spoilage levels for all the SV-processed sausages throughout the storage and addition of rosemary diterpene mixture at 0.02% v/w reduced the microbial growth and improved (p < 0.05) the sensory attributes. Our results demonstrate that sous vide processing minimizes lipid oxidation and microbial growth of chicken sausages with improved product quality and shelf-life at 4 ± 1 ℃.
The health properties of fruit are widely known. Powdered fruit may be a practical format to be offered to the consumer. Nevertheless, the process used to obtain the powder must ensure the maximum retention of the bioactive compounds and the functional value of the fruit while retaining adequate physical properties. The aim of this study was to compare freeze-drying and spray drying as the drying technologies to obtain grapefruit powder. The obtained results allow freeze-drying to be proposed as a better technology than spray drying in order to obtain a product with a higher content of vitamin C and total carotenoids. Moreover, all of the edible part of the fruit is used in this case, so a greater quantity of healthy compounds is preserved and by-product generation is avoided. Adding about 6 g water, 4 g Arabic gum and 0.6 g bamboo fibre/100 g grapefruit pulp is recommended before freeze-drying.
Smoothies represent an excellent and convenient alternative to promote the daily consumption of fruit and vegetables in order to obtain their health-promoting benefits. Accordingly, a green fresh vegetables smoothie (77.2% cucumber, 12% broccoli and 6% spinach) rich in health-promoting compounds was developed. Soluble solids content, pH and titratable acidity of the smoothie were 4.3 ± 0.4°Bx, 4.49 ± 0.01 and 0.22 ± 0.02 mg citric acid 100–1 g fw, respectively. Two thermal treatments to reduce microbial loads and preserve quality were assayed: T1 (3 min at 80 ℃) and T2 (45 s at 90 ℃). Fresh blended unheated samples were used as control (CTRL). The smoothie presented a viscoelastic behaviour. T1 and T2 treatments reduced initial microbial loads by 1.3–2.4 and 1.4–3.1 log units, respectively. Samples were stored in darkness at 5 and 15 ℃. Colour and physicochemical changes were reduced in thermal-treated samples throughout storage, which were better preserved at 5 ℃ rather than at 15 ℃. Vitamin C changes during storage were fitted with a Weibullian distribution. Total vitamin C losses of T1 and T2 samples during storage at 15 ℃ were greatly reduced when they were stored at 5 ℃. Initial total phenolic content (151.1 ± 4.04 mg kg–1 fw) was 44 and 36% increased after T1 and T2 treatments, respectively. The 3-p-coumaroyl quinic and chlorogenic acids accounted the 84.7 and 7.1% relative abundance, respectively. Total antioxidant capacity (234.2 ± 20.3 mg Trolox equivalent kg–1 fw) remained constant after the thermal treatments and was better maintained during storage in thermal-treated samples. Glucobrassicin accounted the 81% of the initial total glucosinolates content (117.8 ± 22.2 mg kg–1 fw) of the smoothie. No glucosinolates losses were observed after T2 treatment being better preserved in thermal-treated samples. Conclusively, a short time–high temperature mild thermal treatment (T2) showed better quality and bioactive compounds retention in a green fresh vegetable smoothie during low temperature storage.
The effect of a pasteurization treatment at 90 ± 2 ℃ for 35 s provided by continuous microwave under different doses (low power/long time and high power/short time) or conventional pasteurization on the quality of orange-colored smoothies and their changes throughout 45 days of storage at 5 ℃ was investigated. A better color retention of the microwave pasteurization- treated smoothie using high power/short time than in conventionally processed sample was evidenced by the stability of the hue angle. The continuous microwave heating increased the viscosity of the smoothie more than the conventional pasteurization in comparison with non-treated samples. Lower residual enzyme activities from peroxidase, pectin methylesterase and polygalacturonase were obtained under microwave heating, specifically due to the use of higher power/shorter time. For this kind of smoothie, polygalacturonase was the more thermo-resistant enzyme and could be used as an indicator of pasteurization efficiency. The use of a continuous semi-industrial microwave using higher power and shorter time, such as 1600 W/206 s and 3600 W/93 s, resulted in better quality smoothies and greater enzyme reduction than conventional thermal treatment.
The potential of fibre concentrate from artichoke stem by-product in bakery application was investigated. The elaboration of fibre concentrate was characterized by an extraction yield of 48.5%. The chemical composition showed high total dietary fibre (85 g/100 g d.m) and low lipid contents (0.5 g/100 g d.m). The fibre concentrate showed good water holding capacity (8.17 g/g) and high oil holding capacity (16.17 g/g). The effect of fibre concentrate incorporation to wheat dough, at level of 2%, on the rheological properties and physical characteristics of bread was also evaluated. The results showed that the addition of fibre concentrate in wheat flour significantly improved (P < 0.05) dough properties inducing an increase of water absorption, stability and tenacity, and a reduction of extensibility and softening in comparison to the dough without fibre. The colour values of the crust and crumb were significantly (P < 0.05) altered by the addition of fibre concentrate. It was also found that incorporation of fibre concentrate to bread produced a comparable specific volume and enhanced the shelf life, as textural studies revealed.
The combined effect of antibrowning dips and controlled atmosphere storage on fresh-cut "Rojo Brillante" persimmon quality was investigated. Persimmon slices were dipped in 10 g L–1 ascorbic acid, 10 g L–1 citric acid or water and were stored in different controlled atmospheres at 5 ℃. Controlled atmosphere conditions were 21 kPa O2 + 10 kPa CO2 (Atm-B), 21 kPa O2 + 20 kPa CO2 (Atm-C), 5 kPa O2 + 10 kPa CO2 (Atm-D) and 5 kPa O2 in the absence of CO2 (Atm-E). Air (Atm-A) was used as a control. Atmospheres with high CO2 concentrations induced darkening, associated with a flesh disorder known as "internal flesh browning". Only the samples placed in Atm-E, and treated with 10 g L–1 ascorbic acid or 10 g L–1 citric acid, controlled enzymatic browning, reduced firmness loss and prevented the "internal flesh browning" disorder. The maximum limit of marketability was achieved in the samples treated with 10 g L–1 citric acid and stored in Atm-E for nine storage days at 5 ℃. The total vitamin C, free radical scavenging activity, total phenolic content and total carotenoids of the fresh-cut "Rojo Brillante" persimmons were affected by maturity stage at harvest, whereas antibrowning dips and controlled atmosphere storage had no clear effect.
To increase the shelf life of edible insects, modern techniques (e.g. freeze-drying) add to the traditional methods (degutting, boiling, sun-drying or roasting). However, microorganisms become inactivated rather than being killed, and when rehydrated, many return to vegetative stadia. Crickets (Gryllus bimaculatus) and superworms (Zophobas atratus) were submitted to four different drying techniques (T1 = 10' cooking, 24 h drying at 60℃; T2 = 10' cooking, 24 h drying at 80℃; T3 = 30' cooking, 12 h drying at 80℃, and 12 h drying at 100℃; T4 = boiling T3-treated insects after five days) and analysed for total bacteria counts, Enterobacteriaceae, staphylococci, bacilli, yeasts and moulds counts, E. coli, salmonellae, and Listeria monocytogenes (the latter three being negative throughout). The microbial counts varied strongly displaying species- and treatment-specific patterns. T3 was the most effective of the drying treatments tested to decrease all counts but bacilli, for which T2 was more efficient. Still, total bacteria counts remained high (G. bimaculatus > Z. atratus). Other opportunistically pathogenic microorganisms (Bacillus thuringiensis, B. licheniformis, B. pumilis, Pseudomonas aeruginosa, and Cryptococcus neoformans) were also encountered. The tyndallisation-like T4 reduced all counts to below detection limit, but nutrients leakage should be considered regarding food quality. In conclusion, species-specific drying procedures should be devised to ensure food safety.
The presence of pesticide residues in potatoes is of concern because of the potential impact to human health due to the high consumption of this vegetable. In this study, aqueous solutions with and without ozone saturation as postharvest wash treatment at pH 4.0, 7.0, and 9.0 were tested to remove chlorothalonil from potatoes. The method used for pesticide analysis has been validated, presenting recovery values of 94–103%, with variations in the repeatability coefficients of ≤10.6%, and a quantification limit of 0.05 mg kg–1. Regardless of pH, treatment with aqueous ozone solutions removed 70–76% of the pesticide present in the potato. In the no-ozone treatments, the percentage average removal of chlorothalonil residues in potatoes was only 36%. Over 24 days of storage, the quality of potatoes washed with aqueous ozone solutions was not significantly different from those washed with pure water.
Low-fat meat products could be excellent carriers for plant sterols, known for their cholesterol-lowering properties. In this study, we developed a protocol for the manufacture of a deli-style turkey enriched with plant sterols (S) at a level sufficient to deliver the maximum plant sterols amount recommended for cholesterol reduction by the European Food Safety Authority (3 g of plant sterols per day) in a 70 g portion. We investigated the stability of the plant sterols and the effects of their addition on the product quality. Plant sterols remained stable during the seven-day storage period. The addition of plant sterols significantly affected some texture parameters, shear force, lipid oxidation, L values and water-holding capacity compared with control (C). Sensory analysis was carried out by an untrained panel (32) using the difference-from-control test between C and S samples to evaluate first the extent of the overall sensory difference and then the extent of sensory difference on colour, texture and flavour. Results indicated that panellists considered the intensity of the difference between C and S samples to be ‘small’. Plant sterols could be used as a potential health-promoting meat ingredient with no effect on plant sterol stability but with some effects on texture and sensory characteristics.
The aim of this work was to study the fermentation process of honey with kefir grains through a comprehensive understanding of its rheological properties, probiotic cell viability, instrumental color parameters and kinetic aspects in a batch bioreactor and during storage. The results showed that kefir grains were well adapted to bioreactor conditions, reaching high levels of cell viability (over 106 CFU mL–1 for total yeast and bacteria), phenolic compounds content (190 GAE/100 g) and acidification after 24 h of fermentation at 30 ℃. Colorimetric analysis showed that lightness (L*) and redness (a*) remained constant, while yellowness intensities (b*) decreased during fermentation time. After 35 days of storage, honey kefir beverage maintained its chemical characteristics and microbial viability as required to be classified as a probiotic product. The Ostwald-de-Waele (R2 ≥ 0.98) and Herschel-Bulkley (R2 ≥ 0.99) models can be used to predict the behavior of honey kefir beverage. The parameters analyzed in this study should be taken into account for industrial production of this novel non-dairy beverage.
The objective of this study was to evaluate the sensory properties and acceptability of pitanga nectar samples prepared with sucrose and different sweeteners (sucralose, aspartame, stevia with 40% rebaudioside A, stevia with 95% rebaudioside A, neotame, and a 2:1 cyclamate/saccharin blend). A total of 13 assessors participated in a quantitative descriptive analysis and evaluated the samples in relation to the descriptor terms. The acceptability test was carried out by 120 fruit juice consumers. The results of the quantitative descriptive analysis of pitanga nectar showed that samples prepared with sucralose, aspartame, and the 2:1 cyclamate/saccharin blend had sensory profiles similar to that of the sample prepared with sucrose. Consumers' most accepted samples were prepared with sucrose, sucralose, aspartame, and neotame. The sweeteners that have the greatest potential to replace sucrose in pitanga nectar are sucralose and aspartame.
There is a growing demand for food supplements containing high amounts of vitamins, phenolic compounds and mineral content that provide health benefits. Those functional compounds have different solubility properties, and the maintenance of their compounds and the guarantee of their homogenic properties need the application of novel technologies. The quality of different drinkable functional foods after thermal processing (0.1 MPa) or high-pressure homogenization under two different conditions (80 MPa, 33 ℃ and 120 MPa, 43 ℃) was studied. Physicochemical characteristics and sensory qualities were evaluated throughout the six months of accelerated storage at 40 ℃ and 75% relative humidity (RH). Aroma and color were better maintained in high-pressure homogenization-treated samples than the thermally treated ones, which contributed significantly to extending their shelf life. The small particle size obtained after high-pressure homogenization treatments caused differences in turbidity and viscosity with respect to heat-treated samples. The use of high-pressure homogenization, more specifically, 120 MPa, provided active ingredient homogeneity to ensure uniform content in functional food supplements. Although the effect of high-pressure homogenization can be affected by the food matrix, high-pressure homogenization can be implemented as an alternative to conventional heat treatments in a commercial setting within the functional food supplement or pharmaceutical industry.
The effects of myofibril protein in pork treated by high hydrostatic pressure combined with heat were investigated. The solubility of myofibril protein significantly increased up to 400 MPa but since then began to decrease up to 600 MPa. The best solubility was shown under all pressure at 35 ℃ and the lowest solubility was observed at 55 ℃. The carbonyl group value, disulfide bond and surface hydrophobicity exhibited pressure-dependent increase in the same manner. Particle size decreased up to 400 MPa and then increased up to 600 MPa, but the turbidity always reduced. The increase of intrinsic fluorescence intensity with red shift and decrease of absorbance around 278 nm with blue shift indicated that protein unfolding and exposure of hydrophobic amino acid occurred with increase of pressure. The second derivative infrared spectra and curve fittings suggested that high pressure induced reduction of β-sheet structures, enhancement of α-helix and random coil and β-turns segments, which was opposite to the effects of temperature. Emission scanning electron microscope assay further demonstrated protein unfolding and aggregation process induced by different pressure and temperature. The data suggested that cooperative effect of moderate pressure and temperature could improve physical-chemical and processing properties of meat.
The physicochemical, compositional and functional properties of flour from green plantains (Musa acuminata) of the large green plantain variety, oyster mushrooms (Pleorotus ostreatus), pineapple peel (Ananas comosus) of the ‘apple pineapple’ variety, yellow peas (Pisum sativum), chickpeas (Cicer arietinum), whole grain rice (Oryza sativa), whole grain corn (Zea mays) and whole grain white quinoa (Chenopodium quinoa) were evaluated by using one-way analysis of variance, Pearson correlations and principal component analysis chemical composition of the eight flours, statistically differed (p < 0.05). Oyster mushroom and yellow pea flours had the greatest protein content (28.92 and 21.02%, respectively), whereas the pineapple peel, peas and corn stood out for their high contents of Fe and Zn. All flours exhibited emulsifying and foaming activities, while hydration and interfacial properties showed statistically significant negative correlations. There was a clear relationship between levels of protein and carbohydrates and gelation and syneresis phenomena in thermally treated flour suspensions. According to principal component analysis of functional, physicochemical and compositional properties, flours were classified into five groups of raw materials: (1) yellow peas, (2) chickpeas, rice, corn and quinoa, (3) green plantain, (4) pineapple peel and (5) oyster mushrooms. Results are promising to formulate mixes and composite flours for fortification and/or enrichment of food products by using different technological processes.
The "Hachiya" persimmon is the most common astringent cultivar grown in California and it is rich in tannins and carotenoids. Changes in the microstructure and some physicochemical properties during high hydrostatic pressure processing (200–400 MPa, 3 min, 25 ℃) and subsequent refrigerated storage were analyzed in this study in order to evaluate the suitability of this non-thermal technology for preservation of fresh-cut Hachiya persimmons. The effects of high-hydrostatic pressure treatment on the integrity and location of carotenoids and tannins during storage were also analyzed. Significant changes, in particular diffusion of soluble compounds which were released as a result of cell wall and membrane damage, were followed using confocal microscopy. The high-hydrostatic pressure process also induced changes in physicochemical properties, e.g. electrolyte leakage, texture, total soluble solids, pH and color, which were a function of the amount of applied hydrostatic pressure and may affect the consumer acceptance of the product. Nevertheless, the results indicate that the application of 200 MPa could be a suitable preservation treatment for Hachiya persimmon. This treatment seems to improve carotenoid extractability and tannin polymerization, which could improve functionality and remove astringency of the fruit, respectively.
The present work studies the use of nanofiltration for the production of red wine concentrate with low alcohol content. Factorial design was applied to measure the influences of transmembrane pressure (10–20 bar) and temperature (20–40 ℃) on the retention of valuable components such as anthocyanins and resveratrol, and on the nanofiltration membrane performance. The highest retention of anthocyanin and resveratrol was achieved at low temperature (20 ℃), while the high transmembrane pressure (20 bar) was found to increase the permeate flux considerably. The experiments demonstrated that nanofiltration appears as a valid technique for the production of low alcohol content red wine concentrate. Reduction of volume by a factor of 4, leads to 2.5–3 times more anthocyanins and resveratrol in the wine concentrates. The final new wine products – obtained by using various forms of reconstitution of the concentrated wine – had low alcohol content (4–6 % by volume) and their sensory attributes were similar to those of the original wine.
An intermittent microwave convective drying method combined with a real-time computer vision technique was employed to detect the effect of drying parameters on color properties of apple slices. The experiments were performed at air temperature of 40 to 80℃, air velocities of 1–2 m/s, microwave powers of 200–600 W, and pulse ratios (PRs) of 2–6. Drying rate and drying time varied from 0.014 to 0.000001 min–1 and 27 to 244 min, respectively. The normalized lightness values had ascending and descending parabolic trends with decrease in product moisture content. With descending dimensionless moisture content, redness, yellowness, color change, hue angle, and chroma were enlarged. The normalized redness values changed from –4 to 3. Models relating drying parameters with drying time, drying rate, and lightness were obtained and found to be significant (P < 0.01). Results indicated that microwave power and PRs had more influence on lightness and color change than other parameters.
Increasingly popular in the West is hummus, a spread that is made with pureed chickpeas and other healthful ingredients. The changes in texture measurements and sensory properties in a novel chickpea flour-based product occurring when water is partially replaced by common ingredients of hummus were investigated. Eleven chickpea gels containing different amounts of minced garlic, lemon juice, curry powder, and inulin were prepared and compared with two control gels. These ingredients were chosen to make the product tastier, appealing, and similar to hummus. Instrumental texture tests were carried out: uniaxial compression, stress relaxation, and texture profile analysis. Quantitative descriptive analysis was used to describe differences in sensory properties perceived by a trained panel, whereas repertory grid method combined with free choice profile was used to determine differences perceived by untrained consumers. Gels with higher curry powder content presented lower force to breakdown, whereas increasing inulin content led to gels with higher hardness. Principal component analysis was applied to instrumental parameters and quantitative descriptive analysis data, whereas generalized Procrustes analysis was applied to free choice profile data. This newly developed chickpea gel may make a nutrition claim with respect to protein ("high in protein," or at least a "source of protein").
In recent years, the growing interest for well-being and healthy lifestyle together with an increasing awareness of the close relationship between food and health have boosted the production of an increasing number of novel goods to be placed in both gluten-containing and gluten-free products market. The objective of this study was to provide a realistic and detailed overview of the current bread-market supply in order to evaluate the overall quality of the available offer in this prioritized food industry area. Twenty commercial breads consisting of gluten (n = 10) and gluten-free (n = 10) samples currently available in the European market have been assessed by physical-chemical, technological, nutritional, and sensory determinations. The quality parameters obtained were related to each other by using Pearson correlations, while sample classification was achieved by applying factor analysis. Higher values for protein and bio-accessible polyphenols content, aroma and taste quality, and low and moderate expected glycaemic index corresponded to gluten containing breads. Although the main distinction was between gluten and gluten-free samples as it was expected, classification of breads allowed differentiating samples with different formulations in terms of presence/absence of alternative, innovative, and nutrient-dense raw materials.
The effect of postharvest vapor heat treatments at 95℃ (4, 7, and 10 s) regarding a conventional sanitizing treatment with 100 mg NaClO l–1 on enzyme activities (phenylalanine ammonia lyase, polyphenol oxidase, and peroxidase), phenolic content, and total antioxidant capacity of fresh-cut pomegranates arils throughout 18 days at 5℃ was studied. Furthermore, the effect of two sustained deficit irrigation (SDI) strategies, compared to a standardly irrigated control (CTRL), was also studied on such quality parameters throughout storage. Arils from CTRL-irrigated fruit registered phenylalanine ammonia lyase, peroxidase, and polyphenol oxidase initial activities of 60.6, 382, and 14.4 U g-1 fw, respectively. Arils from sustained deficit irrigation fruit registered 46–58% lower phenylalanine ammonia lyase values while polyphenol oxidase and peroxidase activities did not register great variants (<9%) among both sustained deficit irrigation treatments. Postharvest vapor heat treatments enhanced phenylalanine ammonia lyase activity in those samples from sustained deficit irrigation fruit although no great peroxidase and polyphenol oxidase (<2–5%) increases were observed. Arils from SDI1 fruit registered higher phenolic content than those values reported for CTRL samples. However, phenolic compounds decreased during storage, in a greater extent for sustained deficit irrigation samples, although 7 s arils achieved better phenolic compounds retention in sustained deficit irrigation samples. Vapor heat treatments reduced up to twofold the total antioxidant capacity losses observed in samples sanitized by conventional NaOCl treatment during shelf life. Conclusively, postharvest vapor heat treatment for 7 and 10 s used to extend the shelf life of pomegranate arils up to 18 days at 5℃ reduced the losses of health-promoting compounds during storage compared to conventional NaOCl sanitizing treatment.
People suffering from lactose intolerance cannot digest milk or lactose-containing foods. Lactose-free diet is essential for them since they do not have the ability to produce lactase to breakdown milk sugar. Physical properties of lactose-free dairy desserts will most probably be different than that of lactose containing ones because of lactose hydrolysis. In this study, it was aimed to analyze the rheological and textural behaviors of different lactose-free dessert formulations containing different gum types and different waxy maize starch and sucrose concentrations. Waxy maize starch was used at concentrations of 0.032 g·mL–1, 0.040 g·mL–1, and 0.048 g·mL–1. In addition to waxy maize starch, guar gum, gum arabic, or -carrageenan at two different concentrations (1.0% w/w and 0.5% w/w) was added. Sucrose was added at concentrations of 0.14 g·mL–1 and 0.10 g·mL–1 in lactose-free desserts. Power law model was found to be suitable to explain the flow behavior of desserts. The storage and loss modulus of lactose-free desserts were higher than that of lactose-containing desserts. The -Carrageenan was found to be the most effective gum for structure build-up.
The main purpose of this study was to develop a pure culture starter for producing kefir. In order to accomplish starter recycling, yeasts (Kluyveromyces marxianus strain, Pichia kudriavzevii clone), lactic acid bacteria (Lactobacillus kefiri strain F4Aa, Lactobacillus kefiri strain NM131-7, Lactobacillus kefiri strain NM132-3, Lactobacillus kefiri strain NM180-3, respectively), and acetic acid bacteria (Acetobacter lovaniensis strain) were entrapped in liquid core capsules based on the distribution ratio in kefir grains. The microbiological, antimicrobial, and chemical properties of kefir made with capsules (M) and kefir grains (K) were measured and compared. According to the results of plate counts in different selective medium, the number of yeasts and bacteria in the liquid core capsules gradually increased and stabilized after eight fermentation cycles. The results of gas chromatography–mass spectrometry showed that almost all the aroma components existed in the two type of kefir, except the ethyl lactate. There was no significant difference in alcohol content, protein content, and fat content, except the acidity and sugar content. Water holding capacity of kefir K was higher than kefir M. There were 14 same free amino acids in kefir M and kefir K, and the content of most free amino acids was similar. In antimicrobial test, there was no significant difference in both kefirs.
The efficacies of organic acid (citric, malic, and gallic acids) treatments at 1% and 2% concentrations on prevention and removal of Bacillus subtilis biofilms were investigated in this study. The analyses were conducted on microtitration plates and stainless steel coupons. The biofilm removal activities of these organic acids were compared with chlorine on both surfaces. The results showed that citric acid treatments were as powerful as chlorine treatments for prevention and removal of biofilms. The antibiofilm effects of malic acid treatments were higher than gallic acid and less than citric acid treatment. When the antibiofilm effects of these acids and chlorine on the two surfaces were compared, the prevention and removal of biofilms were measured higher on microtitration plates than those on stainless steel coupons. Higher reductions were obtained by increasing concentrations of sanitizers on 24-hour biofilm with 20-minute sanitizer treatments for removal of biofilms.
The aim of this research was to evaluate the effect of ultraviolet-C light on physicochemical, bioactive, microbial, and sensory characteristics of carrot beverages. Beverages were formulated with different concentrations of carrot juice (60, 80, and 100% [v/v]) and treated with ultraviolet-C light at different flow rates (0, 0.5, 3.9, and 7.9 mL s–1) and times (5, 10, 15, 20, and 30 min), equivalent to ultraviolet-C dosages of 13.2, 26.4, 39.6, 52.8, and 79.2 J cm–2. Total soluble solids, pH, and titratable acidity were not affected by the ultraviolet-C light treatment. Ultraviolet-C light significantly affected (p < 0.05) color parameters of pure juice; however, at low concentration of juice, total color change was slightly affected (E = 2.0 ± 0.7). Phenolic compounds (4.1 ± 0.1, 5.2 ± 0.2, and 8.6 ± 0.3 mg of GAE 100 mL–1 of beverage with 60, 80, and 100% of juice, respectively) and antioxidant capacity (6.1 ± 0.4, 8.5 ± 0.4, and 9.4 ± 0.3 mg of Trolox 100 mL–1 of beverage with 60, 80, and 100% of juice, respectively) of carrot beverages were not affected by ultraviolet-C light treatment. Microbial kinetics showed that mesophiles were mostly reduced at high flow rates in carrot beverages with 60% of juice. Maximum logarithmic reductions for mesophiles and total coliforms were 3.2 ± 0.1 and 2.6 ± 0.1, respectively, after 30 min of ultraviolet-C light processing. Beverages were well accepted (6–7) by judges who did not perceive the difference between untreated and Ultraviolet-C light treated beverages.
To prevent enzymatic browning of fresh-cut ‘Rojo Brillante’ persimmon, different combinations of ascorbic acid (AA) and citric acid (CA) with calcium chloride (CaCl2) were tested in fruit harvested at two maturity stages (MS1 and MS2). Color, firmness, sensory quality, total vitamin C, radical scavenging activity, total phenolic content, and carotenoids were evaluated over nine days of storage at 5 ℃. Antibrowning dips reduced enzymatic browning if compared with the control samples. Selecting fruits with good firmness and the addition of 10 g/l CaCl2 help prevent loss of firmness of fresh-cut "Rojo Brillante" persimmons treated with acidic solutions as antibrowning agents to control enzymatic browning. The limit of marketability of the persimmon fruit processed at MS1 was significantly reduced by the burst of the disorder known as "flesh browning," and only the samples treated with 10 g/l CA + 10 g/l CaCl2 maintained a limit of marketability close to seven days. At MS2, all the antibrowning solutions allowed a limit of marketability of seven storage days at 5 ℃. Nutritional quality was not affected by either antibrowning dips or cutting processes, but MS at harvest was.
Thermal inactivation kinetics of Listeria innocua CECT 910 inoculated in a vegetable beverage at three pH conditions (4.25, 4.75, and 5.20), four levels of temperature (50, 55, 60, 65℃), and different treatment times (0–75 min) were obtained. Survival curves did not follow a log-linear relationship and consequently were fitted to various mathematical models: Weibull, Geeraerd, Cerf with shoulder, and the modified Gompertz equation. Results indicated that the best model for the treatment conditions was the modified Gompertz equation, which provides the best goodness-of-fit and the lowest Akaike information criterion value. Sensitivity analysis indicated that the most influential factors affecting the final microbial load were temperature and time in the case of the higher temperature level (65℃) and time in the case of the lower temperature level (50℃).
Total phenolics (TP), vitamin C, antioxidant activity and colour of preserved peppers were evaluated at 4, 25 and 50 ℃ storage during 30-day intervals. Except for 4 ℃, TP decreased during storage at 25 ℃ and 50 ℃, being softer for fortified samples with β-CDs. The protective effect was evident, since 50 ℃ samples containing β-CDs exhibited lower TP loss (19%) than control samples (38%) for 5 months storage. A decrease in the vitamin C content was observed for both samples as time and temperature progressed. In samples stored at 50 ℃ the protective effect of β-CD only was evident at the first month, since fortified samples showed lower vitamin C loss (10%) than control samples. The fortified samples with β-CDs exhibited lowest antioxidant activity loss (40%) during 90-day storage at 50 ℃, than control samples (64%). The colour changes were in line with those observed for total phenolics and at the end of study, the presence of 1% β-CDs delayed the darkening of samples at both (25 and 50 ℃) storage conditions.
In the present study, the effectiveness of different vegetable proteins (pea protein isolate, soy protein isolate and zein from maize) at two different ratios (1% and 5%) on product yield and physical properties of spray-dried pulpy tomato juice was investigated. Additionally, these proteins were compared with whey protein concentrate which has a superior effect on spray dried products at the same concentrations. Additionally, plain tomato juice was also spray dried for comparison with vegetable proteins. The product yield of the tomato powders dried with the vegetable proteins was lower than with the whey protein concentrate. Among vegetable proteins, the highest product yield was produced with 1% soy protein isolate. In all products, there was a slight colour difference between the reconstituted tomato powders and the raw tomato juice, which indicated that pulpy tomato juice can be spray dried with minor colour change. All powders had unique free-flowing properties estimated as Carr index and Hausner ratio due to their large particles.
A numerical study on 2D natural convection in cylindrical cavities during the sterilization of liquid foods was performed. The mathematical model was established on momentum and energy balances and predicts both the heating dynamics of the slowest heating zone (SHZ) and the lethal rate achieved in homogeneous liquid canned foods. Two sophistication levels were proposed in viscosity modelling: 1) considering average viscosity and 2) using an Arrhenius-type model to include the effect of temperature on viscosity. The remaining thermodynamic properties were kept constant. The governing equations were spatially discretized via orthogonal collocation (OC) with mesh size of 25 x 25. Computational simulations were performed using proximate and thermodynamic data for carrot-orange soup, broccoli-cheddar soup, tomato puree, and cream-style corn. Flow patterns, isothermals, heating dynamics of the SHZ, and the sterilization rate achieved for the cases studied were compared for both viscosity models. The dynamics of coldest point and the lethal rate F0 in all food fluids studied were approximately equal in both cases, although the second sophistication level is closer to physical behavior. The model accuracy was compared favorably with reported sterilization time for cream-style corn packed at 303 x 406 can size, predicting 66 min versus an experimental time of 68 min at retort temperature of 121.1 ℃.
The fogging of strawberries using a environmentally friendly sanitizer mixture of peracetic acid (5%) and hydrogen peroxide (20%) was performed in a model chamber and modeled as a function of the concentration (3.4, 20.0, 60.0, 100.0 and 116.6 µL sanitizer L–1 air chamber) and the treatment time (5.7, 15.0, 37.5, 60.0 and 69.3 min). The sanitizer fogging was adequate for reducing total mesophilic microbial and yeasts and moulds counts of fruits until seven days of storage at 2℃. However, sanitizer oxidant properties adversely affected the content of total anthocyanins, total phenolics, vitamin C, and antioxidant capacity to various degrees, with some deleterious changes in the fruits color, depending on the fogging conditions. A multiple numeric response optimization was developed based on 2.0 log microbiological reduction, maximum phytochemicals and antioxidant capacity retentions, with no changes in the fruits color, being the optimal fogging conditions achieved: 10.1 µL sanitizer L–1 air chamber and 29.6 min. The fogging of strawberries at these conditions may represent a promising postharvest treatment option for extending their shelf-life without affecting their sensory quality and bioactive properties.
Growth curves were evaluated for aerobic mesophilic and psychrotrophic bacteria, Pseudomonas spp. and Staphylococcus spp., grown in raw, salted, and cooked chicken breast at 2, 4, 7, 10, 15, and 20 ℃, respectively, using the modified Gompertz and modified logistic models. Shelf life was determined based on microbiological counts and sensory analysis. Temperature increase reduced the shelf life, which varied from 10 to 26 days at 2 ℃, from nine to 21 days at 4 ℃, from six to 12 days at 7 ℃, from four to eight days at 10 ℃, from two to four days at 15 ℃, and from one to two days at 20 ℃. In most cases, cooked chicken breast showed the highest microbial count, followed by raw breast and lastly salted breast. The data obtained here were useful for the generation of mathematical models and parameters. The models presented high correlation and can be used for predictive purposes in the poultry meat supply chain.
Modelling and predicting the simultaneous competitive growth of Escherichia coli and starter culture of lactic acid bacteria (Fresco 1010, Chr. Hansen, Hørsholm, Denmark) was studied in milk at different temperatures and Fresco inoculum concentrations. The lactic acid bacteria (LAB) were able to induce an early stationary state in E. coli. The developed model described and tested the growth inhibition of E. coli (with initial inoculum concentration 103 CFU/mL) when LAB have reached maximum density in different conditions of temperature (ranging from 12 ℃ to 30 ℃) and for various inoculum sizes of LAB (ranging from approximately 103 to 107 CFU/mL). The prediction ability of the microbial competition model (the Baranyi and Roberts model coupled with the Gimenez and Dalgaard model) was first performed only with parameters estimated from individual growth of E. coli and the LAB and then with the introduced competition coefficients evaluated from co-culture growth of E. coli and LAB in milk. Both the results and their statistical indices showed that the model with incorporated average values of competition coefficients improved the prediction of E. coli behaviour in co-culture with LAB.
There is currently a high demand for natural and fresh-cut fruits. In this study, natural additives were applied to fresh-cut nectarines: (1) control, nontreated; (2) wedges were dipped in an antibrowning solution containing calcium ascorbate (AB); (3) and (4) wedges were dipped in an AB plus natural antimicrobial agents (vanillin or cinnamic acid, respectively). After these treatments, fresh-cut nectarines were packed and stored at 5 ℃ for eight days. The treatments AB+Vanillin and AB+Cinnamic inhibited microbial counts when compared with control and AB-only samples. The application of these solutions did not impart any aromas or off-flavors to nectarines and maintained firmness during the shelf-life period. AB solutions inhibited polyophenol oxidase action and reduced browning while stabilizing the soluble phenolic content, increasing consumer’s acceptance. Nectarine wedges assimilated the ascorbic acid from the AB solution and retained it during the shelf-life period. The combination of an antibrowning agent and natural antimicrobials helped to control microbiological growth while maintaining high-quality parameters. They can be an attractive "green" alternative for organic fresh-cut products to other chemical sanitizers such as chlorine.
The growing commercial importance of xylooligosaccharides is based on their beneficial health properties, particularly their ability to stimulate the growth and activity of intestinal bacteria such as Bifidobacterium and Lactobacillus species. Xylooligosaccharides are less sweet, acid, and heat stable, with low recommended levels of intake compared to other oligosaccharides. In view of the consumer demand for foods with low sugar, low fat, and high fiber contents, they are suitable for incorporation into bakery products. In this study, we have developed wheat-based cookies incorporated with xylooligosaccharides at 5%, 10%, and 15% levels. The nutritive value and physicochemical properties of the cookies changed with xylooligosaccharides incorporation; both crude fiber and dietary fiber contents increased by 14% and 35%, respectively, in the enriched cookies. The moisture levels increased with increase in the percentage of xylooligosaccharides incorporated. Cookies with 5% xylooligosaccharides were found most acceptable, although the color was slightly darker compared to the control, while cookies with 10% and 15% xylooligosaccharides were softer and darker and therefore less acceptable. Enrichment with xylooligosaccharides at 5% provided a product stable for 21 days at room temperature (25 ± 2℃). The storage stability of cookies with higher levels of xylooligosaccharides was less than the 5% xylooligosaccharides cookies and control. The retention of the prebiotic xylooligosaccharides in the products was relatively high (74%).
Gluten-free baked products for celiac sufferers are essential for healthy living. Cereals having gluten such as wheat and rye must be removed from the diet for the clinical and histological improvement. The variety of gluten-free foods should be offered for the sufferers. In the study, gluten-free wafer formulas were optimized using corn, rice and buckwheat flours, xanthan and guar gum blend as an alternative product for celiac sufferers. Wafer sheet attributes and textural properties were investigated. Considering all wafer sheet properties in gluten-free formulas, better results were obtained by using 163.5% water, 0.5% guar and 0.1% xanthan in corn formula; 173.3% water, 0.45% guar and 0.15% xanthan gum in rice formula; 176% water, 0.1% guar and 0.5% xanthan gum in buckwheat formula. Average desirability values in gluten-free formulas were between 0.86 and 0.91 indicating they had similar visual and textural profiles to control sheet made with wheat flour.
Alternatives are needed for long-term preservation of European pears (Pyrus communis L.) after the ban on diphenylamine. "Rocha" pear fruit harvested at commercial maturity were treated with 1-methylcyclopropene (1-methylcyclopropene, SmartFresh™) and diphenylamine and stored at 0 ℃, 90–95% relative humidity, under normal atmosphere for up to six months or under controlled atmosphere (controlled atmosphere, 3 kPa O2 + 0.7 kPa CO2) for up to 9.4 months. At 312 nl l–1, 1-methylcyclopropene reduced softening and yellowing, and increased soluble solids content during shelf life in comparison with fruit treated with diphenylamine. 1-Methylcyclopropene at 312 nl l–1 was also more effective than diphenylamine in reducing superficial scald and internal browning disorders. 1-Methylcyclopropene at 150 nl l–1 had little effect on ripening-related changes but was effective against physiological disorders of pears stored in regular atmosphere or under controlled atmosphere. Delayed controlled atmosphere slightly reduced internal browning disorders but increased superficial scald. 1-Methylcyclopropene at 312 nl l–1 reduced physiological disorders in "Rocha" pear under refrigerated storage and delayed ripening-related softening and color changes during shelf life. At 150 nl l–1, 1-methylcyclopropene is as effective as diphenylamine against storage disorders without ripening impairment.
Consumer demand for safe and nutritious fruits and vegetables has given rise to the development of a number of nonthermal food preservation techniques. Recent studies have highlighted that antioxidant activity of fruits and vegetables plays an important role in human health. In this paper, the influences of nonthermal preservation technologies, including pulsed electric field, radiation processing, dense phase carbon dioxide, ozone processing, and edible coatings, on the antioxidant capacity and related compounds in fruits and vegetables are reviewed. The proposed mechanisms and future trends are also discussed to accelerate the further commercialization and exploration of these novel technologies, which will, in turn, help to promote human health.
A combination of different hurdles, such as mild heat (54 ℃ for 10 min) or pulsed electric field (25 pulses; 25 kV/cm; 3.35 kJ/cm per pulse) treatments and essential oils constituents (carvacrol, citral, and (+)-limonene), to reduce spoiling bacteria and yeasts in apple juice was evaluated. For this purpose, the heat and pulsed electric field resistances of five strains of Leuconostoc spp. and five Saccharomyces spp. strains were assayed, achieving different inactivation levels for each treatment and strain. For instance, Leuconostoc fallax 74, the most heat-resistant strain, was the second-most sensitive strain to pulsed electric field. The most resistant strains were exposed to combined processes of heat or pulsed electric field and 0.2 µl/ml essential oils constituents. The combination of heat and essential oils constituents proved to be synergistic against both microorganisms in apple juice. The most effective was the combination of mild heat and carvacrol, which caused the inactivation of 99% of L. fallax 74 and 99.99% of Saccharomyces cerevisiae CECT 1172 cells. Therefore, this study shows the great potential of carvacrol, citral, and (+)-limonene in combined treatments with mild heat to achieve a higher degree of inactivation of spoiling microorganisms in apple juice, and thus, to extend its shelf life.
The aim of this study was to measure the impact of heating on the sensory properties of blue-veined cheeses in order to characterise their sensory properties and to identify their specific sensory typology associated with physicochemical parameters. Sensory profiles were performed on a selection of Protected Designation of Origin (PDO) cheeses representing the four blue-veined cheese categories produced in the Massif Central (Fourme d’Ambert, Fourme de Montbrison, Bleu d’Auvergne and Bleu des Causses). At the same time, physicochemical parameters were measured in these cheeses. The relationship between these two sets of data was investigated. Four types of blue-veined cheeses displayed significantly different behaviour after heating and it is possible to discriminate these cheese categories through specific sensory attributes. Fourme d’Ambert and Bleu d’Auvergne exhibited useful culinary properties: they presented good meltability, stretchability and a weak oiling-off. However, basic tastes (salty, bitter and sour) are also sensory attributes which can distinguish heated blue cheeses. The relationship between the sensory and physicochemical data indicated a correlation suggesting that some of these sensory properties may be explained by certain physicochemical parameters of heated cheeses.
Although slow food movement is a well-known movement nowadays, in order to make it more widespread to the society, necessity to develop and to adapt new techniques has become inevitable for healthier consumption age. For this purpose, possibility of increased usage of healthy foods with addition of natural extracts using new techniques came out from relevant questionaries applied to people of different age groups. In this study, specific properties of supercritical carbon dioxide at distinct temperatures and water in subcritical conditions were used to obtain extracts rich in water-soluble organic compounds. Experiments were carried out at pressures of 10, 20, 30, and 40 MPa and temperatures ranging from 40 to 200 ℃ with and without modifier for 2 h of extraction time. The flow rate was kept at 4 and 1 ml/min for CO2 and water, respectively. The highest water-soluble organic compound recovery yield was 78.10%. Results were supported by marketing strategies to announce this new application and products to the society. Group of sample questions was prepared to investigate (a) frequency of staple food usage, (b) the brand names and relevant reasons that bring up consumers to buy specifically same branded products, (c) knowledge about the ingredients and how advertising effects purchasing decision, etc. Finally, efficiency increase in slow food consumption was proved with supercritical fluid technology to draw attention to the health of consumers with newer and functional healthy foods.
Freshly prepared, hand-pressed strawberry fruit juice was exposed to ultraviolet radiation (254 nm) at room temperature (25 ℃ ± 1 ℃) for 15, 30 and 60 min with 0 min serving as control. Results revealed decrease in pH, total soluble solids and titratable acidity, while colour parameters (L*, a* and b* values) and clarity of juice (% transmittance) increased significantly. All the results corresponded to exposure time to ultraviolet radiation. Bioactive compounds (total phenolics, ascorbic acid and anthocyanins) decreased along with a recorded reduction in polyphenol oxidase enzyme and 1,1-diphenyl-2-picryl hydrazyl radical scavenging activities, which were again dependent on exposure time. Results on the microbial studies showed significant reduction by 2-log cycles in aerobic plate count as well as in total yeast and mould counts. Though negative results were observed for certain parameters, this is the first time it was endeavoured to demonstrate the impact of ultraviolet radiation radiation on freshly prepared, hand-pressed strawberries juice.
Tiger nut is a tuber used to produce tiger nut milk that yields a high quantity of solid waste, which can be dried and used as fiber source. The objective of this paper was to evaluate the quality of gluten-free bread formulated with different tiger nut-derived products in order to substitute soya flour (which is an allergen ingredient) and, at the same time, increase the use of tiger nut-derived products. Four gluten-free formulations based on corn starch and containing tiger nut milk, tiger nut milk by-product, tiger nut flour, or soya flour (as reference formulation) were studied. Tiger nut milk increased G' of gluten-free batter and rendered breads with the softest crumb (502.46 g ± 102.05), the highest loaf-specific volume (3.35 cm3/g ± 0.25), and it was mostly preferred by consumers (61.02%). Breads elaborated with tiger nut flour had similar characteristics than soya flour breads (except in color and crumb structure). The addition of tiger nut milk by-product resulted in a hard (1047.64 g ± 145.74) and dark (L* = 70.02 ± 3.38) crumb bread, which was the least preferred by consumers. Results showed that tiger nut is a promising ingredient to formulate gluten-free baked products.
The growing demand for fresh-like food products has encouraged the development of hurdle technology of non-thermal processing. In this study, freshly squeezed Chokanan mango juice was treated by paired combinations of sonication (for 15 and 30 min at 25 ℃, 40 kHz frequency) and UV-C treatment (for 15 and 30 min at 25 ℃). Selected physicochemical properties, antioxidant activities, microbial inactivation and other quality parameters of combined treated juice were compared to conventional thermal treatment (at 90 ℃ for 60 s). After thermal and combined treatment, no significant changes occurred in physicochemical properties. A significant increase in extractability of carotenoids (15%), polyphenols (37%), flavonoids (35%) and enhancement in antioxidant capacity was observed after combined treatment. Thermal and combined treatment exhibited significant reduction in microbial load. Results obtained support the use of sonication and UV-C in a hurdle technology to improve the quality of Chokanan mango juice along with safety standards.
The unattractive appearance of gluten-free bread still remains a challenge in gluten-free breadmaking. In response to this, additives such as dairy products, soya and eggs have been used to improve the quality of gluten-free bread, but with limited success. In recent years, enzymes (transglutaminase and cyclodextrinase) and hydrocolloids (carboxymethylcellulose and hydroxypropylmethylcellulose) have become the main focus for the improvement of gluten-free bread. Transglutaminase has been shown to improve the dough viscoelasticity and decrease crumb hardness (6.84–5.73 N) of the resulting bread. Cyclodextrinase also enhances dough viscoelasticity, resulting in an improvement of 53% in shape index and crumb firmness. Similarly, hydroxypropylmethylcellulose improves gas retention and water absorption of dough and reduces crumb hardening rate of the resulting bread, while carboxymethylcellulose significantly increases dough elasticity (60–70 BU) and bread volume (230–267 cm3/100 g bread).
Millet has long been known as a good source of fiber and antioxidants, but only lately started to be exploited by food scientists and food industry as a consequence of increased consumer awareness. In this study, doughs and breads were produced using millet flour in different ratios (10, 20, 30, 40, and 50%) to white, dark, and whole wheat flour. The flour blends were evaluated in terms of rheological and thermo-mechanical properties. Fundamental rheological measurements revealed that the viscosity of the flour formulations increases with wheat flour-extraction rate and decreases with the addition of millet flour. Doughs behavior during mixing, overmixing, pasting, and gelling was established using the Mixolab device. The results of this bread-making process simulation indicate that dough properties become critical for the flour blends with millet levels higher than 30%. The breads were evaluated for volume, texture, and crumb-grain characteristics. The baking test and sensory evaluation results indicated that substitution levels of up to 30% millet flour could be used in composite bread flour. High levels of millet flour (40 and 50%) negatively influenced the loaf volume, crumb texture, and taste.
An efficient ultrasonic-assisted enzymatic extraction technique was applied to extracting phenolics from broccoli inflorescences without organic solvents. The synergistic model of enzymolysis and ultrasonication simultaneously was selected, and the enzyme combination was optimized by orthogonal test: cellulase 7.5 mg/g FW (fresh weight), pectinase 10 mg/g FW, and papain 1.0 mg/g FW. The operating parameters in ultrasonic-assisted enzymatic extraction were optimized with response surface methodology using Box–Behnken design. The optimal extraction conditions were as follows: ultrasonic power, 440 W; liquid to material ratio, 7.0:1 mL/g; pH value of 6.0 at 54.5 ℃ for 10 min. Under these conditions, the extraction yield of phenolics achieved 1.816 ± 0.0187 mg gallic acid equivalents/gram FW. The free radical scavenging activity of ultrasonic-assisted enzymatic extraction extracts was determined by 1,1-diphenyl-2-picrylhydrazyl·assay with EC50 values of 0.25, and total antioxidant activity was determined by ferric reducing antioxidant power assay with ferric reducing antioxidant power value of 0.998 mmol FeSO4/g compared with the referential ascorbic acid of 1.184 mmol FeSO4/g.
Whole fruit pomegranate (Punica granatum L.) juice of the ‘Wonderful’ cultivar was characterized through the elucidation of its antiradical kinetics and activity using 2,2-diphenyl-1-picrylhydrazyl as the antiradical probe. Time-dependent concentration of 2,2-diphenyl-1-picrylhydrazyl during its reduction by the juice has been adjusted through a non-linear parametric fitting. Determined total antiradical activity was high, able to reduce 84.58 µmol/l of 2,2-diphenyl-1-picrylhydrazyl per concentration unit of juice (µl/ml), equivalent to a concentration of 42.29 mmol/l of ascorbic acid (or Trolox). Partial antiradical activities due to the fast-, medium- and slow-kinetics were 49.09, 18.16 and 17.33 µmol/l of reduced 2,2-diphenyl-1-picrylhydrazyl per concentration unit of juice (µl/ml), respectively. The corresponding rate constant for the fast-, medium- and slow-kinetics were 1 = 6.03, 2 = 0.169 and 3 = 0.0094 (μl l)/(ml µmol min), respectively. This methodology allows characterization of samples through the accurate determination of the kinetics of their antiradical features, avoiding the use of empirical approximations that hinder the realistic comparison between extracts independently of their origin.
Rheological and physical properties of edible coating formulations containing gelatin, cellulose nanofibers (CNFs), and glycerol are characterized. Measured properties are analyzed in order to optimize edible coating thickness. Results show that coating formulations density increases linearly with gelatin concentration in presence of CNFs. Surface tension decreases with either gelatin or CNF concentration increases. Power law model well described the rheological behavior of edible coating formulations since determination coefficient was high (R2 > 0.98) and standard error was low (SE < 0.0052). Formulations showed pseudoplastic (shear-thinning) flow behavior and no time-dependent features were observed. The flow behavior index was not significantly affected by any factor. Consistency coefficient increases with gelatin concentrations but it decreases with glycerol concentrations.
The aim of this study was to evaluate physical and sensory characteristics of low-sodium tilapia steaks restructured with microbial transglutaminase. Polyphosphate (0.4%), condiment mixes—onion powder and garlic powder (2.5%), water (10.0%), transglutaminase (1.0%), and different types of salts (1.5%) were mixed with non-commercial sized fillets. Substitution of NaCl by KCl or MgCl2 (at 50% each) affected quality attributes and decreased (P < 0.05) consumer acceptability. The tri-salt steaks (KCl, MgCl2, and NaCl at 1:1:2 ratio) improved some attributes and increased (P < 0.05) acceptability and purchase intention. We conclude that potassium and magnesium chlorides are possible replacers of salt (NaCl) in restructured tilapia steaks and potentially decrease the risk factor for heart failure associated with high sodium consumption.
Tilapia skin gelatin, pig skin gelatin, and their mousse premixes were exposed to UV irradiation for 103, 206, and 309 kJ/cm2. All samples after 309 kJ/cm2 exposure exhibited a significant increase in gel strength, gel forming ability as well as viscosity of solutions. It was shown that UV treatment could also improve the pig skin gelatin foam stability and foam formation ability compared to those of tilapia skin gelatin. Nevertheless, the panelists gave the lowest scores to mousse made with 309 kJ/cm2 UV-irradiated premix mousse pig skin gelatin. Tilapia skin gelatin could be used as a substitute ingredient for premix mousse made from pig skin gelatin.
The aim of this work was to determine the effect of microwave blanching on the levels of selected quality parameters in frozen Agaricus bisporus. Before freezing, mushrooms underwent one of the following treatments: blanching in water; blanching in a solution of sodium metabisulphite and citric acid; microwaving for 5 min; and combined blanching (first in water, then in a microwave oven). Products were freeze stored for 8 months at –25 ℃. Frozen storage resulted in decreased levels of vitamin B1, total polyphenols and antioxidant activity of 10–49%, as well as an increase in polyphenol oxidase activity compared with products immediately after freezing. The values for most colour parameters and whiteness intensity decreased, while cream, yellow, brown and grey saturation increased. There was a considerable deterioration in sensory quality, particularly colour. Microwave-blanched products had significantly higher dry matter, ash, vitamin B1 and B2 content than the remaining products as well as half the polyphenol oxidase activity. Total polyphenols and antioxidant activity were highest in the product blanched in the sodium metabisulphite solution, followed by the microwave-blanched product. Compared with the product blanched using sodium metabisulphite, microwave-blanched mushrooms showed slightly greater darkening but were superior in flavour and aroma.
The impact of the incorporation of 10% w/w of hydrolyzable chestnut tannin into pigskin gelatin (G) films plasticized with glycerol (Gly) on the physicochemical properties as well as the in vitro antioxidant and antibacterial effectiveness against food-borne pathogens such as Escherichia coli and Streptococcus aureus was investigated. A higher tendency to both redness (a*) and yellowness (b*) coloration characterized gelatin films incorporated with chestnut tannin. The reduced lightness (L) and transparency of gelatin–chestnut tannin films plasticized with 30% w/w Gly might be associated with certain degree of phase separation which provoked the migration of the plasticizer to the film surface. The incorporation of chestnut tannin and glycerol affected the chemical structure of the resultant films due to the establishment of hydrogen interactions between components as revealed by Fourier transform infrared spectroscopy. These interactions reduced gelatin crystallinity and seemed to be involved in the substantial decrease of the water uptake of films with tannin, irrespective of the glycerol level. Such interactions had minor effect on tensile properties being similar to those of the control films (without chestnut tannin) at the same glycerol level. Films modified with 10% w/w chestnut tannin showed significant (P < 0.05) 2,2-diphenyl-1-picrylhydrazyl radical scavenging activity, ca. from 0 ± 0.033 to 87.1 ± 0.002% for chestnut tannin-free and chestnut tannin-containing gelatin films. The limited inhibitory activity of films incorporated with 10% w/w chestnut tannin against the selected bacteria evidenced by disk diffusion method probably resulted from the interactions within the film restricting the diffusion of the active agent into the agar medium. The more modest protective effect observed against a Gram-positive bacterium (S. aureus) was also discussed.
Buckwheat is one of the most valuable pseudo-cereals in terms of its nutritional composition, and it is suitable for celiac patients because of its gluten-free characteristic. However, gluten is the main structure-forming protein responsible for the development of structure in baked products. Therefore, it is a challenge to produce high-quality gluten-free products. Transglutaminase addition is a relatively common application used in the production of gluten-free baked goods. The objective of this study was to investigate the combination of buckwheat flour with rice and corn flour at different levels in gluten-free cookie formulations and the impact of transglutaminase on the quality of cookies. Quality parameters evaluated were proximal chemical composition, spread ratio, color, and textural parameters (hardness and fracturability). Spread ratio, protein, crude fiber, ash content, and also b* and hardness values were significantly (p < 0.05) affected by flour combinations. Further, addition of transglutaminase resulted in increased moisture content, spread ratio, and fracturability but decreased hardness values.
A study has been carried out in order to determine the effect of the lactic acid bacteria inoculation time on the kinetic of vinification and on chemical and sensory characteristics of Cabernet Franc wines. Traditional vinifications, with lactic acid bacteria inoculated after completion of alcoholic fermentation were compared with vinifications where yeast and bacteria were co-inoculated at the beginning of vinification. One commercial yeast strain and an autochthonous Oenococcus oeni strain (C22L9), previously identified and selected at our laboratory, were used. Monitoring of alcoholic and malolactic fermentations was carried out by yeast and lactic acid bacteria counts and by measuring
White, food-grade sorghum was milled to flour of varying extraction rates (60%, 80%, and 100%) and pin-milled at different speeds (no pin-milling, low-speed, and high-speed) to create flours of both variable composition and particle size. Flours were characterized for flour composition, total starch content, particle size distribution, color, damaged starch, and water absorption. Bread was characterized for specific volume, crumb structure properties, and crumb firmness. Significant differences were found (P < 0.05) in the composition of sorghum flours of varying extraction rate, most notably for fiber and total starch contents. Flour particle size and starch damage were significantly impacted by extraction rate and speed of pin-milling. Water absorption increased significantly with increasing extraction rate and pin-milling speed. Breads produced from 60% extraction flour had significantly higher specific volumes, better crumb properties, and lower crumb firmness when compared with all other extractions and flour types. The specific volume of bread slices ranged from 2.01 mL/g (100% extraction, no pin-milling) to 2.54 mL/g (60% extraction, low-speed pin-milling), whereas the firmness ranged from 553.28 g (60% extraction, high-speed pin-milling) to 1096.26 g (commercial flour, no pin-milling). The bread characteristics were significantly impacted by flour properties, specifically particle size, starch damage, and fiber content (P < 0.05).
The effects of 1-methylcyclopropene (1-MCP) on shelf life, fruit visual quality and nutritional quality were investigated. Netted melons were treated with air (control) and 0.6 µl l–1 1-MCP at 25 ℃ for 24 h, and then stored at 25 ℃ or 10 ℃ for 10 days. 1-MCP significantly extended the shelf life, inhibited weight loss and delayed firmness decline of melon fruits. Ethylene production was also inhibited and respiration rate was declined. 1-MCP retarded 1-aminocyclopropane-1-carboxylic acid (ACC) increases and inhibited ACC synthase and ACC oxidase activity. Moreover, 1-MCP treatment reduced the decrease in total soluble solids and titratable acidity, as well as the decrease of the content of sugars (sucrose, fructose and glucose). These results indicated that 1-MCP treatment is a good method to extend melon shelf life and maintain fruit quality, and the combination of 1-MCP and low temperature storage resulted in more acceptable fruit quality.
This study was carried out to investigate the frying performance of Kizakinonatane (Brassica napus) oil during deep-fat frying of frozen French fries with/without replenishment. Commercial regular canola oil was used for comparison. The frying oils were used during intermittent frying of frozen French fries at 180, 200, and 220 ℃ for 7 h daily over four consecutive days. The Kizakinonatane oil exhibited lower levels of total polar compounds, carbonyl value, and viscosity as well as comparable color (optical density) values to that of the canola oil. The monounsaturated fatty acid/polyunsaturated fatty acid ratios were lower than that of canola oil, whereas the polyunsaturated fatty acid/saturated fatty acid ratios are higher than that of canola oil after heating. Results showed that fresh Kizakinonatane oil contains higher levels of acid value, viscosity, optical density values, tocopherols, and total phenolics contents than that of canola oil. Replenishment with fresh oil had significant effects on all chemical and physical parameters, except the acid value of the Kizakinonatane oil during frying processes. Based on the results, the Kizakinonatane oil is inherently suitable for preparing deep-fried foods at high temperatures.
Two sweet cherry cultivars (‘New Star’ and ‘Sweet Heart’) were chosen to explore the impact of passive modified atmosphere packaging on the eating quality and health-promoting properties of fruit. Packaged and unpackaged fruits were stored at 0 ℃ for 15 or 30 days, followed by zero or three days at 20 ℃, after which the analyses were undertaken. In most cases, modified atmosphere packaging helped preserving higher firmness values and reducing the incidence of alterations and decay in both cultivars, but the effects on other physicochemical attributes were different for each cultivar. Partial least squares regression procedures were used to reveal relationships among the different variables assessed. Generally, fruits displaying higher antioxidant capacity were also characterised by higher values for firmness and titratable acidity, in turn related to better acceptability scores in both cultivars. However, the attributes contributing most to acceptability were different in each case. In ‘New Star’ fruit, acceptability was closely related to the perception of cherry flavour. In this cultivar, acetaldehyde content was related to the perception of off-flavours, while ethanol content was found to associate to soluble solids and to the perception of sweetness. In contrast, acceptability of ‘Sweet Heart’ fruit was related mainly to the perception of firmness and, to a lower extent, of sweetness.
Functional advantages of probiotics combined with interesting composition of oat were considered as an alternative to dairy products. In this study, fermentation of oat milk with Lactobacillus reuteri and Streptococcus thermophilus was analysed to develop a new probiotic product. Central composite design with response surface methodology was used to analyse the effect of different factors (glucose, fructose, inulin and starters) on the probiotic population in the product. Optimised formulation was characterised throughout storage time at 4 ℃ in terms of pH, acidity, β-glucan and oligosaccharides contents, colour and rheological behaviour. All formulations studied were adequate to produce fermented foods and minimum dose of each factor was considered as optimum. The selected formulation allowed starters survival above 107/cfu ml to be considered as a functional food and was maintained during the 28 days controlled. β-glucans remained in the final product with a positive effect on viscosity. Therefore, a new probiotic non-dairy milk was successfully developed in which high probiotic survivals were assured throughout the typical yoghurt-like shelf life.
The drying kinetics of longan (Dimocarpus longan Lour.) pulp processed by microwave vacuum under different microwave levels (2.67, 5.33, 8.00, and 10.67 W/g) was investigated (pressure controlled at –85 ± 2 kPa) in the present study. It was found that the drying rate of longan pulp was dependent on the microwave power, and the rehydration rate increased from 1.96 to 2.17 with the increase of microwave power from 2.67 to 10.67 W/g. Among nine selected thin layer models, the microwave vacuum drying of longan pulp was well represented by five models, which were Page, Modified Henderson and Pabis, Wang and Singh, Logarithmic, and Midilli models. Furthermore, the results of statistical analysis indicated that the Midilli model could describe the best experimental data. In addition, scanning electron microscope observation showed that the microwave vacuum-dried longan pulp had a porous structure.
The objective of this study was to characterize naturally fermented dry sausages produced without the use of microbial starters and to determine which odour-active compounds are responsible for their aroma. The traditional manufacture was responsible for different chemical characteristics and consumer's acceptance. The volatile compounds detected in the headspace comprised a complex mixture of volatile compounds derived from bacterial metabolism (mainly esterase activity of Staphyloccoci), spices and lipid auto-oxidation. The odour-active volatile compounds were identified using gas chromatography coupled to olfactometry (GC-O) using the detection frequency method. The aroma profile was characterized by the presence of several compounds such as acetic acid, ethyl butanoate, hexanal, methional, 1-octen-3-ol, benzeneacetaldehyde and 4-methyl-phenol. However, naturally fermented sausages were also characterized by numerous esters, both ethyl and methyl esters, which impart a wide variety of fruity notes.
Yeasts are tolerant to acid pH values, are able to grow in anaerobic media and have minimum nutrition requirements. These capabilities enable them to survive and even grow in foods prepared from acid fruits or vegetables. Among yeasts, Candida is one of the genus most frequently isolated from fruit juices. Bacteriocins and essential oils from spices and aromatic herbs are an alternative to preservatives and other technological treatments and have the advantage that their natural origins do not lead to consumer rejection. However, before the food industry uses them on a large scale, it is necessary to know their effects on microorganisms. The objective of this research was to study the effect of different concentrations of nisin, thymol, carvacrol and cymene on the growth of Candida lusitaniae in pH 5 broth at 25 ℃, and their potential uses as food preservatives. The addition of nisin at the concentrations tested (up to 3 µmol L–1) did not affect the yeast growth. Thymol, carvacrol and cymene completely inhibited the yeast growth at concentrations over 1 mM for at least 21 days at 25 ℃. Below this concentration, inhibitions on yeast growth were observed at increasing concentrations. The effect of thymol was also proved in tomato juice. This study indicates the potential use of essential oils for preservation of minimally processed foods.
Chitosan-based edible films were prepared and subjected to cross-linking reactions using sodium tripolyphosphate and/or to beeswax coating on both films interfaces. In addition, chitosan–beeswax emulsion-based films were produced. The goal of these modifications of the chitosan films was the improvement of their barrier to water vapor and to decrease their affinity to liquid water maintaining or improving the mechanical and optical properties of the original chitosan films. The cross-linking with tripolyphosphate decreased both the water vapor permeability and the water absorption capacity to about 55% and 50% of that of the original chitosan films, respectively. However, there was an increase in the films stiffness, revealed by the increased Young modulus from 42 kPa up to 336 kPa. The multilayered wax–chitosan–wax films exhibited a similar improvement of the barrier properties to water vapor, with the advantage of maintaining the mechanical properties of the original chitosan films. However, these wax-coated films showed a higher water absorption capacity, which is believed to be a consequence of water entry into small pores between the film and the wax layers. Regarding the film samples subjected to cross-linking and further coating with beeswax, a similar behavior as the uncoated cross-linked films was observed. The emulsion-based composite films were characterized by a substantial decrease of the water vapor permeability (40%), along with a decrease in their stiffness. Regarding the optical properties, all films presented a yellowish color with similar values of lightness, chroma, and hue.
A previously described phage infecting Escherichia coli O157:H7 was added to raw and cooked beef pieces at concentrations ranging from 101–108 plaque forming units/cm2 to either low (<100 CFU/cm2) or high (104 CFU/cm2) concentrations of host bacterial cells. Incubation for up to 24 h was performed at 5℃ and 24℃ to simulate refrigerated and room temperature storage/temperature abuse. Surviving bacteria were enumerated during the incubation period, with phages being counted at the first and last sampling times. Significant reductions of E. coli O157:H7 of the order of >4 log10 CFU/cm2 at both temperatures could be achieved compared to phage-free controls. There was a trend for greater inactivation to occur with increasing phage concentration. While re-growth of surviving cells occurred in nearly all samples incubated for 24 h at 24℃, these conditions are not typical of those experienced by perishable foods. It was concluded that phages can be used to reduce the concentration of a bacterial pathogen on meat, but the concentration of phages needs to be high (>4–5 log10 plaque forming units/cm2) for reductions to occur. A concentration of the order 8 log10 plaque forming units/cm2 was needed to achieve a 4 log10 CFU/cm2 reduction.
An unsupplemented peach jam and four peach jam samples prepared by supplementing the former with increasing amounts of Aloysia citriodora aqueous extract were subjected to sensory testing. A trained panel of eight assessors initially identified (reaching consensus) the relevant sensory attributes and then rated the jam samples on an individual basis. The jam samples were later evaluated for overall liking and willingness to purchase by a group of 95 interested consumers, who also provided their individual appraisal of the sensory features of the various samples by responding to an open-ended question. Overall, consumers appeared not to accept the sensory modifications introduced in traditional peach jam by the addition of A. citriodora extract, even though they were expressly acquainted with its health benefits. The degree of acceptance of the extract supplement decreased significantly with increasing amounts of extract in the jam. The groups identified to have the least and the greatest tolerance to the sensory modifications introduced in the supplemented jams differed in gender distribution, with male consumers having a greater tolerance than females.
The combination of temperature and atmosphere composition for storage of Pyrus communis L. ‘Rocha’ treated with 1-methylcyclopropene was investigated. Fruits treated with 312 nl l–1 1-methylcyclopropene were stored at 0 ℃ and 2.5 ℃ in air and controlled atmosphere (CA) (3.04 kPa O2+ 0.91 kPa CO2). Fruits were removed from storage after 14, 26 and 35 weeks, transferred to shelf-life at approximately 22 ℃ and assessed for ripening and quality, symptoms of superficial scald and internal browning and the accumulation of biochemical compounds related to scald after 0, 1 and 2 weeks. Superficial scald occurred only in fruits stored for 35 weeks in air at 2.5 ℃. Levels of conjugated trienols and α-farnesene increased during the first 26 weeks in storage, remaining constant thereafter. During shelf-life, conjugated trienols were higher in fruits stored in air at 2.5 ℃. Internal browning developed in shelf-life after 26 weeks at 2.5 ℃. Pears in air at 2.5 ℃ were not able to stand a 2-week shelf-life after 35 weeks of storage, while fruits stored at 0 ℃ under CA ripened slowly after the same storage period. The retention of firmness during shelf-life of 1-methylcyclopropene-treated ‘Rocha’ pear can be overcome by elevating the storage temperature from 0 ℃ to 2.5 ℃, but CA is a required complement to avoid excessive softening after long-term storage. The ratio carotenoid/chlorophyll increased during storage and shelf-life, as plastids senesced. CA reduced the rate of chlorophyll loss during the first 14 weeks in storage, but its effect was reduced afterwards. ‘Rocha’ pear treated with 1-methylcyclopropene had a similar post-harvest behaviour during long-term storage at 0 ℃ in air or at 2.5 ℃ under CA.
The aim of this study was to evaluate the effect of a modified atmosphere (5% and 10% of CO2) and calcium lactate treatment on the respiratory metabolism of minimally processed persimmon. A static system to measure changes in the composition of the headspace was used. Composition, texture and colour were also analysed. Persimmon slices were evaluated immediately after the washing treatment and after the O2 composition had decreased to 17% to avoid changes in the metabolic pathway. All samples were stored at 4 ℃. The results showed that modified atmosphere did not affect compositional properties, although there was a slight increase in pH values at the end of each treatment. Calcium lactate treatment reduced the respiration rate, in terms of O2, in samples kept in air. Additionally, a calcium lactate effect was immediately observed on mechanical properties after the washing stage. On the other hand, luminosity and b* coordinate decreased in unwashed and calcium lactate samples kept in 5% CO2.
The aim of the study was to investigate physical and chemical properties of preparations of water soluble arabinoxylans (arabinoxylan-enriched flour) obtained by industrial method and their derivatives (obtained by hydrolysis and cross-linking of aranbinoxylans), as well as their impact on baking properties of rye flours. Additionally, these results were compared with highly purified arabinoxylans prepared by laboratory method and well characterized in the literature. Flour enriched with arabinoxylans was obtained by industrial method involving air separation of flour particles. It was characterized by 8.6% arabinoxylan content, lack of insoluble material and substantial residue (67%) of starch and dextrins. The addition of all industrial method preparations in amount of 10% (i.e. approx. 1% water soluble arabinoxylans), to rye flours resulted in an increase in water absorption, bread volume and decrease in hardness of the bread crumb and the effect was especially strong in the case of flour type 720. Due to the easiness of isolation procedure, industrial method preparation could be advised as an improver for rye bread making.
Biodegradable edible films prepared using proteins are both economically and environmentally important to the food packaging industry relative to traditional petroleum-derived synthetic materials. In the present study, the mechanical and water vapor barrier properties of casted canola protein isolate edible films were investigated as a function of protein (5.0% and 7.5%) and glycerol (30%, 35%, 40%, 45%, and 50%) content. Specifically, tensile strength and elongation, elastic modulus, puncture strength and deformation, opacity, and water vapor permeability were measured. Results indicated that tensile strength, puncture strength, and elastic modulus decreased, while tensile elongation and puncture deformation values increased as glycerol concentration increased for both 5.0% and 7.5% canola protein isolate films. Furthermore, tensile strength, puncture strength, and elastic modulus values were found to increase at higher protein concentrations within the canola protein isolate films, whereas puncture deformation values decreased. Tensile elongation was found to be similar for both canola protein isolate protein levels. Canola protein isolate films became more transparent with increasing of glycerol concentration and decreasing of canola protein isolate concentration. Water vapor permeability value was also found to increase with increasing glycerol and protein contents. Overall, results indicated that canola protein isolate films were less brittle, more malleable and transparent, and had greater water vapor permeability at higher glycerol levels. However, as protein level increased, canola protein isolate films were more brittle, less malleable and more opaque, and also had increased water vapor permeability.
Barley (Hordeum sativum) is a good source of dietary fibre, particularly β-glucan. Effect of 10, 20, 30 and 40% barley flour on the rheological characteristics of dough and quality characteristics of south Indian parotta was studied. Use of increasing amount of barley flour from 0 to 40% increased farinograph water absorption and decreased stability, increased extensograph resistance to extension and decreased extensibility, decreased amylograph set back and increased peak viscosity values. Sensory analysis showed that use of barley flour above 30% brought about adverse effect on the quality of parotta. Addition of combination of 2% dry gluten powder and 0.001% xylanase enzyme, XY (combination of improvers) decreased elasticity, increased extensibility of the dough and quality of parotta with 30% BF. During 48 h of storage, parottas with 30% barley flour remained softer than control parotta. The total dietary fibre and β-glucan contents of parotta with 30% BF were 2.0 and 10.5 times higher than the control parotta.
The nutritional quality changes of the fresh-cut kailan-hybrid broccoli were compared with those of the ‘Parthenon’ cv. throughout 15 days at 2 ℃, 5 ℃ and 8 ℃ under air and modified atmosphere packaging. Florets showed higher dietary fiber content than stems. The total protein content of kailan-hybrid florets was 2.2-fold higher than that of ‘Parthenon’ cv. and higher amounts of S, Ca, Mg, Fe, Sr, Mn, Zn and Cu were found. However, ‘Parthenon’ florets registered higher initial total phenolics content than the kailan-hybrid edible part, followed by an increase throughout shelf-life favored at 5 ℃ and 8 ℃ under modified atmosphere packaging (5–7 kPa O2 + 14–15 kPa CO2). Modified atmosphere packaging stored samples at 8 ℃ showed higher individual phenolics content than modified atmosphere packaging stored samples at 2 ℃. The initial total antioxidant capacity of the kailan-hybrid edible part was higher than that of ‘Parthenon’ cv. florets. In conclusion, the kailan-hybrid florets generally showed healthier properties on the analyzed bioactive compounds, except total phenolic content, compared to the conventional ‘Parthenon’ cv.
Prosopis species are generally fast-growing, drought-resistant, nitrogen-fixing trees or shrubs. Fruits of Prosopis spp are indehiscent pods, where pericarp is formed by the epicarp, light brown in colour, and fibrous nature; the mesocarp known as pulp, which is rich in sugars; and the endocarp. The aim of this work was to obtain a fibre concentrate from the pods of Prosopis chilensis Mol. (Stuntz) and to determine the chemical, physical, and technological properties of the pod flour (PF) and of a fibre concentrate or pod purified flour (PPF). Acetone, ethanol, and water at different conditions of time and temperature were used in the purification process. PF showed 53.7 g/100 g of total sugar content, 4.2 g/100 g of reducing sugar content, 41.8 g/100 g of total dietary fibre, 35.8 g/100 g of insoluble fibre, and 6.0 g/100 g of soluble fibre content. The PPF has a total sugar content of 3.8 g/100 g, reducing sugar content of 2.2 g/100 g, total dietary fibre content of 80.8 g/100 g, insoluble fibre content of 75.1 g/100 g, and soluble fibre content of 5.7 g/100 g. The scanning electron microscopy analysis showed the existence of voids in the structure of PPF flour, which reveals the efficiency of the purification process with a high decrease in the total sugar content.
This article focuses on the location and content of some bioactive compounds in three different California sweet pepper types (red, green and yellow). The location was studied using different microscopic techniques, such as scanning electron microscopy at low temperatures (cryo-SEM) and light microscopy. Several physicochemical properties of the samples (carotenoid content, total soluble phenol content, antioxidant activity, dietary fibre content, total soluble solids content, pH and textural properties) were also examined. The degree of compaction and structuring of the cell wall was found to be indirectly related to solute transport at the cellular level and directly related to total dietary fibre content. The three types of pepper displayed formation and accumulation of phenolic aggregates and an active circulation of solutes. Yellow pepper tissue had the most labile cell walls and the highest transport of solutes. Red peppers could be suitable for obtaining extracts rich in carotenoid compounds, yellow peppers for obtaining phenolic compounds with a high antioxidant activity and green peppers for extracts with high dietary fibre content.
The influence of maltodextrin with different concentrations (0–30%) and dextrose equivalent (dextrose equivalent 10 and dextrose equivalent 15) under different environmental stresses (pH 3–8, NaCl 0–500 mM, and sucrose 0–20%) on the stability of whey protein concentrate/-carrageenan stabilized sesame oil-in-water emulsions was investigated by mean particle diameter, particle size distribution, -potential, microstructure, and viscosity. Sesame oil-in-water emulsions containing anionic droplets stabilized by interfacial membranes comprising whey protein concentrate/-carrageenan/maltodextrin (15% sesame oil, 0.5% whey protein concentrate, 0.2% -carrageenan, 0.02% sodium azide and 0–30% maltodextrin with dextrose equivalent of 10 and 15, 5 mM phosphate buffer, pH 7) were produced using a homogenizer. The primary emulsion (1°) containing whey protein concentrate-coated droplets was prepared by homogenizing. The secondary emulsion (2°) containing whey protein concentrate–-carrageenan in the absence or presence of maltodextrin was produced by mixing the 1° emulsion with an aqueous -carrageenan in the absence or presence of maltodextrin solution. There were no significant changes in mean droplet diameter and -potential of droplets at any maltodextrin concentration (0–30%) or dextrose equivalent (10 and 15) after 24 h storage. The apparent viscosity of emulsions increased when the maltodextrin concentration increased. The 2° emulsion containing 15% maltodextrin with dextrose equivalent of 10 had the stability to aggregation at pH 6–8, NaCl ≤ 300 mM, and sucrose 0–20%. The addition of maltodextrin to emulsion can be used to form emulsions with different physicochemical properties for various applications in food processing (for example, encapsulation).
Anchovy protein hydrolysates with high free radical-scavenging activity were prepared by endogenous and commercial enzymes. Various hydrolytic factors (commercial protease composition, protease concentration, temperature, and reaction time) were optimized. Using a single-factor experiment, three commercial proteases (Protamex, Flavourzyme 500 MG, and Alcalase 2.4 L) were selected for further optimization using a simplex lattice design. The optimum composition of Protamex:Flavourzyme 500 MG:Alcalase 2.4 L was found to be 1.1:1.0:0.9. The hydrolytic conditions (commercial protease concentration, temperature, and reaction time) for the optimum protease composition were optimized using a Box-Behnken design. The optimum hydrolytic conditions were as follows: total commercial protease concentration of 3.27%, pH of 7.5, temperature of 55.4℃, and reaction time of 2.7 h. Under these conditions, hydrolysate with a 1, 1-diphenyl-2-picryhydrazyl scavenging activity of 84.7% was obtained. Meanwhile, a degree of hydrolysis of 33.2% and high protein nitrogen recovery of 87.5% were achieved. The amino acid composition of the hydrolysates demonstrated that they have high nutritional value, thereby suggesting that the hydrolysates have potential to be used as raw material for functional food.
The effect of high pressure processing (HPP) (400 and 600 MPa for 1 and 5 min) and the stability during storage were studied in two ready to heat vegetable meals: meal A, mainly composed by pumpkin and broccoli, and meal B, mainly composed by eggplant, zucchini, chard and spinach. The treatment at 600 MPa/5 min was the most effective to reduce the initial microbial loads of the meals and maintained better the microbial safety during storage. HPP had no effect on the physico-chemical and sensory properties. HPP at 600 MPa increased the antioxidant activity of the meal A. In contrast HPP reduced the antioxidant activity of the meal B, although in general high levels of antioxidants were maintained after processing and during storage. In conclusion, treatments at 600 MPa for 5 min were the most suitable to increase the shelf-life of the meals without affecting their physico-chemical, antioxidant and sensory properties.
In this study, the effect of grain moisture content (12–20%), temperature (140–180 ℃), and time (5–15 min) of roasting on the quality attributes of sorghum grain was studied. The response functions were rheological attributes of powder flowability, color, water absorption capacity, and sensory acceptability. These response functions could be correlated (r ≥ 0.91, p ≤ 0.01) with the independent variables by second order polynomials. Higher temperature and longer roasting time had a detrimental effect on color and sensory acceptability of product. An increase in moisture content of grain induced lower cohesion characteristics in the flour as evidenced by less energy for compression. Raw sorghum flour exhibited highest peak viscosity of 297 BU compared to only 32–71 BU for roasted samples. Roasted sorghum flour exhibited less shear-thinning phenomenon compared to raw sample, and was more stable towards retrogradation. Optimum condition for maximum sensory acceptability was achieved with a grain moisture content of 16–20% and temperature 161–179 ℃ for 12 min of roasting.
Listeria-infecting bacteriophages (listeriaphages) can be used to control Listeria monocytogenes in the food industry. However, the sensitivity of many of seafood-borne Listeria strains to phages has not been reported. This research investigated the host ranges of three listeriaphages (FWLLm1, FWLLm3 and FWLLm5) by the formation of lytic zones and plaques on host lawns and in vitro lysis kinetics of listeriaphage FWLLm3. The study also predicted the phage titres required to lyse host cells. The host ranges of the phages were determined using 50 L. monocytogenes strains, of which 48 were isolated from the seafood industry and two from clinical cases. Of the 50 strains, 36 were tested at 25 and 30 ℃ and the remainder (14) at 15 and 25 ℃. Based on the formation of either discrete plaques or lytic zones (host kill zones), the host ranges of FWLLm1, FWLLm3 and FWLLm5 were about 87%, 81% and 87%, respectively, at 25 ℃. Six L. monocytogenes strains from the seafood environment were insensitive to all three phages, while the other seafood strains (42) were phage-sensitive. The adsorption rate constant (k value) of listeriaphage FWLLm3 was between 1.2 x 10–9 and 1.6 x 10–9 ml/min across four host strains in tryptic soy broth at 25 ℃. The cultures (at 3–4 log colony-forming unit (CFU/ml) were completely lysed (<1 log CFU/ml) when cultures were infected with FWLLm3 at > 8.7 log phage-forming units (PFU/ml) for 30 min. Re-growth of phage-infected cultures was not detected after 24 h. The effective empirical phage titre was similar to the calculated titre using a kinetic model. Results indicate the potential use of the three phages for controlling L. monocytogenes strains in seafood processing environments.
This study attempts to report the effect of high pressure processing (100, 200 and 300 MPa for 5, 10 and 15 min at 27 ± 2 ℃) on quality and shelf life extension of ‘Bombai’ variety peeled litchi fruits during refrigerated storage (5 ℃). High pressure processing significantly increased total colour difference, browning index, drip loss and total soluble solids, whereas pH decreased after processing. Also, ascorbic acid content significantly decreased after high pressure processing and retention of 83.5% was observed. Texture profile analysis showed that pressurization significantly affected firmness and increased cohesiveness, gumminess, springiness and chewiness of litchi fruits. Pressure-induced firming effect was observed at 100 and 200 MPa pressure. A maximum of 3.29, 3.24 and 3.77 log10 cycles reduction in aerobic mesophiles, yeast & mold and psychrotrophs count, respectively, was achieved after pressurization of 300 MPa for 10 and 15 min treatments. During storage, samples treated at 300 MPa for 10 and 15 min showed relatively minimal changes in physico-chemical attributes, textural parameters and maintained lower viable microbial counts. Treatments at 300 MPa for 10 min and 15 min were found to enhance the shelf life of litchi fruits up to 32 days as compared to 12 days of untreated during refrigerated storage (5 ℃).
The main objective of this study was to evaluate the effect of muscle type and frozen storage on the quality of restructured meat preparations from undervalued Iberian muscle to make use of meat from a high-quality and natural pig production system. The effect of two muscle types (i.e. white-glycolytic (W) and red-oxidative (R)) and frozen storage (lasting 0, 30, 60 and 90 days) on quality characteristics were assessed. Significant differences were found between the W and R Iberian restructured preparations in most physicochemical and some colour, texture and sensory traits, and in the fatty acid profile and oxidative measurements, suggesting that the R muscles are more suitable; however, the microbial contamination should be reduced. Frozen storage reduced but did not eliminate the initial microbial contamination, and it enhanced some quality traits in the Iberian restructured preparations, i.e. increased a* values, cohesiveness and juiciness and decreased adhesiveness and pastiness, without negatively affecting any parameter. Thus, frozen Iberian restructured preparations are recommended to be commercialized. In addition, the implementation or revision of Hazard Analysis and Critical Control Point is recommended to reduce microbial contamination.
Pervaporation has been used to obtain aroma concentrates from brown crab boiling juice. The boiling juice and the obtained permeate have been analysed by Headspace Solid Phase Dynamic Extraction Gas Chromatography/Mass Spectrometry. The effect of feed temperature on the pervaporation performance of the membrane has been analysed. The permeate aroma profile, at 25 ℃ and 40 ℃, was different from that of the boiling juice. Enrichment factors for some of the volatile compounds were much lower than those obtained in model aqueous dilute solutions. Pervaporation performance can be significantly improved by modifying the permeant circuit to include two condensation stages.
The aim of this study was to develop a minimally processed persimmon product by applying different concentrations of thyme essential oil or lemon essential oil on the product in order to increase its shelf life. Essential oils were applied on cut persimmon in a preliminary stage of immersion, and the samples were then stored at 4 ℃ for seven days. Moisture content, soluble solids content, antioxidant capacity, total phenols, pH, optical and mechanical properties and microbiology counts were periodically analysed. Noteworthy was that the application of thyme essential oil in the washing stage improved the preservation of the fruits’ colour. All samples would be considered safe according to microbiology requirements and based on the period of study, regardless of the type of essential oil applied.
Sulfites
Comprehensive research is required to achieve the optimization of the antioxidant protection through baby foods, in particular, the commercially available fruit-based baby foods. This study investigated the physicochemical properties, ascorbic acid (AA), total carotenoids (TC), total phenolic content (TPC), trolox equivalent antioxidant capacity (TEAC) and oxygen radical absorbance capacity (ORAC) of 23 different commercially available fruit-based baby foods. The main contribution to the total antioxidant capacity (trolox equivalent antioxidant capacity and oxygen radical absorbance capacity) was provided by ascorbic acid, followed by phenolic compounds, in accordance with a mathematical equation obtained from the data: TEAC = 245.906 + 7.727 x (AA) + 1.988 x (TPC) – 0.008 x (TC) and ORAC = 318.662 + 2.775 x (AA) – 0.531 x (TPC) – 0.073 x (TC). Moreover, a positive correlation (r = 0.346, p < 0.05) was found for oxygen radical absorbance capacity and trolox equivalent antioxidant capacity methods. Baby foods with different kind of fruits used as ingredients showed higher antioxidant capacity. Among the commercial baby foods analysed in this work, that treated by gentle steam cooking process had high levels of bioactive compounds and antioxidant capacity.
The use of new ingredients like inulin for fat replacement is of wide application in the food industry. The aim of the present work was to reduce the fat content on ice cream formulations. It was possible to reduce up to 25% of butyric and vegetable fats with 3% of inulin, with good textural and sensory characteristics of the final product. The substitution of fat with inulin increased the ice cream mix viscosity, improved air incorporation, and produced ice cream with soft and homogeneous textures. Color characteristics were not affected by the replacement. Hedonic sensory analysis showed that optimized fat-reduced inulin ice cream was not perceived different to commercial vanilla ice cream.
The retention of solutes in the ice formed in a falling-film freeze concentrator (multi-plate freeze-concentrator) was analysed. Solutions of fructose, glucose and sucrose and a simulated juice with initial concentrations of 5, 10, 15 and 20 °Brix were freeze concentrated. The ice produced in the four steps of the process retains solutes at levels of 1.0–8.8 °Brix (expressed as solute mass fraction in the ice). The recovery of these solutes during thawing can increase overall system efficiency. All thawing steps were carried out dividing the sample in 10 fractions at 20 ℃. The first thawed fractions showed solute concentrations that were 1.9–3.3 times higher than the mean solute mass fraction in the ice, while the last fractions of ice showed very low levels of retained solutes, less than 0.2 times the mean solute mass fraction in the ice. It was found that fractionated thawing can recover most of the solute content in the ice. The procedure presented in the present study allows the determination of the solute concentration achieved in the various thawing fractions and predicts the thawing time required for a given form factor, melting temperature and initial solute mass fraction in the ice.
The pomegranate (Punica granatum L.) fruit has a long history of human consumption and possesses notable antioxidant and cardiovascular properties. This work evaluated the feasibility to provide a new functional beverage based on a dealcoholized red wine matrix supplemented by a pomegranate extract. The potential bioactive compounds in the pomegranate extract, punicalagin A and B and ellagic acid, were analyzed during the downstream process in order to evaluate the functional dose in the final beverage. The addition of pomegranate extract to the dealcoholized red wine resulted in a product with more intense yeast odor, acidity, yeast flavor, and astringency and with a less intense berry flavor. Consumer acceptance of the product was also investigated and the results revealed the existence of a niche of consumers willing to consume dealcoholized wine enriched with pomegranate extract. After tasting, 50% and 40% of those consumers initially interested by this product concept declared to be interested to purchase the control sample and the functional beverage, respectively. The daily consumption of two servings of 250 mL of this new pomegranate-enriched dealcoholized wine provides 82 mg of total ellagitannins, corresponding to the sum of punicalagin A and B and ellagic acid.
This study investigated the survival of encapsulated potential probiotic Lactobacillus plantarum which isolated from fermented cocoa beans. -carrageenan was used to encapsulate the probiotic. Encapsulation techniques such as emulsification, freeze-drying or extrusion were adopted to encapsulate the probiotic. Freeze-drying and extrusion methods showed higher (p < 0.05) efficiency (89.48 ± 3.21 and 92.26 ± 1.45%, respectively) in encapsulating the probiotic compared to the emulsification method (82.19 ± 0.71% efficiency). Freeze-dried encapsulated probiotic L. plantarum was selected for further survival analysis as greater amount of beads were produced compared to the extrusion method. Freeze-dried probiotic was found to have significantly (p < 0.05) higher tolerance to acid at pH 2 with higher survival percentage compared to non-encapsulated probiotic. However, freeze-drying encapsulation was proven not to enhance the resistance of the probiotic to bile salt as evidenced by the one log colony reduction as for the non-encapsulated probiotic. Further modification of freeze-drying encapsulation technique is needed to enhance the survival of the encapsulated potential probiotic L. plantarum toward bile salt in the future.
Fresh-cut industry needs novel disinfectant to replace the use of chlorine. Ozone is one of the most powerful oxidizing agents and is applied in gaseous or aqueous form for sanitation purposes. However, the strong oxidative effect could affect the nutritional and sensorial quality, in particular, when time of washing is extended. For that reason, the overall impact of ozonated water (0.4 mg/L) dipping applied during 1, 3 and 5 min compared to control washed in water during 5 min was studied in tomato slices stored during 14 days at 5 ℃. According to the results, ozonated water treatment of 3 min achieved the best firmness retention, microbial quality (mesophilic, psychrotrophic and yeas load) and reduced the consumption of fructose and glucose. The use of ozonated water did not affect the total acidity, pH, total solid soluble, organic acid as ascorbic, fumaric or succinic acid and the sensorial parameters, which were only affected by storage time. However, the poor appearance, aroma and overall quality obtained in all treatments prevented shelf life of 14 days and the quality at acceptable levels was established in 10 days at 5 ℃. It is recommended to wash tomato slices with 0.4 mg/L ozonated water for 3 min only. Extending treatment duration did not improve the microbiological quality, possibly due to the extra time permitting the ozone to react with other components of the fruit tissue, undermining the antimicrobial benefits.
The effect of postharvest 1-methylcyclopropene and/or cold storage application on texture quality parameters during storage was determined. The changes in fruit quality (including weight loss, firmness, total soluble solids content, and ethylene production), cell wall material (including water-soluble fraction, ethylenediaminetetraacetic acid-soluble fraction, Na2CO3-soluble fraction, 4% KOH-soluble fraction, and 14% KOH-soluble fraction), and cell wall hydrolase activities (including polygalacturonase, endo-1,4 -β-
The objective of this study was to determine the lethal effectiveness of pulsed electric fields on the inactivation of the porcine blood endogenous microflora. Furthermore, the impact of pulsed electric field application on physico-chemical and sensory properties in this medium should be proved. Blood samples from a commercial abattoir in Germany were processed by a continuous pilot plant-pulsed electric field system at electric field strength of 11 kV/cm for treatment times of 163 and 209 µs. The applied pulse frequencies of 134 and 175 Hz correspond to an energy input of 91 and 114 kJ/kg, respectively. In these conditions, the effectiveness of pulsed electric field processing on microbial inactivation was limited: 1.35 log10 CFU/mL reduction of total aerobic plate count (p < 0.05), 1.0 log10 CFU/mL for Pseudomonas spp. (p < 0.05), 0.97 and 0.66 log10 CFU/mL reduction for Enterobacteriaceae and sulfite-reducing anaerobic bacteria, respectively. However, the storage experiment (14 days at +3 ℃) showed a significant reduced growth of total aerobic plate count (p < 0.05) and Pseudomonas spp. (p < 0.05) in the pulsed electric field-treated blood samples. Pulsed electric field processing leads to a complete hemolysis of the red blood cells, in addition significant decreased L* (lightness), a* (redness) and b* (yellowness) values (p < 0.0001) were observed. Furthermore, changes in the sensory attributes color (changed from red to dark brown) and odor (changed from fresh to musty and tangy) were noticed.
The potential of using the unwashed mince of farmed meagre as raw material for the preparation of heat-induced gel products was assessed taking into account the effect of age (small size <1 kg meagre vs commercial size >2 kg meagre), lower salt levels (1.0%, w/w, vs 2.5%, w/w), and microbial transglutaminase (MTGase) incorporation (0.0%, w/w, vs 0.5%, w/w). Heat-induced gel products from >2 kg fish were of superior quality. Salt reduction from 2.5% to 1.0% (w/w) was detrimental for textural quality, particularly, of gels prepared from >2 kg meagre mince. MTGase addition improved texture. Moreover, MTGase incorporation led to a greater importance of non-covalent hydrophobic bonding.
The aim of this work was to test the feasibility of using ultrasonic measurements to estimate the fat content and identify the fat sources used in formulated dry-cured pork meat products. For that purpose, dry-cured sausages were prepared using different fat sources (two Iberian pork backfats, Iberian lard, and sunflower oil) and contents (fat content from 3% to 17% wet basis) and characterized by measuring the ultrasonic velocity (at 2 ℃, 6 ℃, 10 ℃, 15 ℃, 20 ℃, and 25 ℃), fatty acid profile, thermal behavior, and composition. The fatty acid composition affected the melting behavior of the sausages, which also involved different ultrasonic velocities, depending on the fat source used for the sausage formulation. Significant (p < 0.05) linear relationships were established between the ultrasonic velocity and the percentage of melted fat, by means of which the sausage batches were differentiated according to the fat source used. The ultrasonic velocity temperature dependence allowed the determination of the fat content (explained variance 96.1%) by measuring the ultrasonic velocity in the dry-cured sausages at 2 ℃ and 25 ℃ and using a semi-empirical equation. Therefore, the ultrasonic measurements could be considered as a reliable tool for the characterization and differentiation of formulated dry-cured meat products with different fat sources and contents.
Pepper plants (Capsicum annuum L. cv Lamuyo) were treated with a mix of nitrophenolates either by foliar spray or in the irrigation system, and its effect on crop yield and the content of nutritive and bioactive compounds in fruit were analysed at harvest and after post-harvest storage. Treatments were applied at 2-week intervals from the development of first floral bunch (1 March) to end of August. Pepper fruits were harvested at commercial ripening stage (red surface colour) along the growth cycle (from May to September). Total yield (cumulative kilogram per plant) was increased (4.5% more) by nitrophenolate treatments due to significant increases in fruit mass, although the number of fruits per plant was unaffected. Pepper fruit quality (weight, firmness and pericarp thickness), its content in nutritive (sugars and organic acids) and bioactive compounds (vitamin C and total phenolics) and antioxidant activity were also enhanced by nitrophenolate treatments at the three harvested dates assayed (end May, mid July and end August). In addition, all these parameters were maintained at higher levels in treated peppers during storage, while diminutions in these parameters occurred generally in control fruit. Thus, nitrophenolate treatments were able to improve crop yield as well as the nutritional value and antioxidant properties of peppers at harvest and after fruit storage.
Rice–blackgram batter is a raw material for many traditional convenience foods in Asia. Reformulation of traditional convenience food by replacing white rice with whole rice (brown rice) is a novel method to reduce the consumption of refined grain and increase the intake of whole grain in our diet. In this study, rheological properties of rice–blackgram batter was investigated while replacing white rice with brown rice at five levels (T1 – 0% replacement (control), T2 – 25% replacement, T3 – 50% replacement, T4 – 75% replacement, and T5 – 100% replacement). The shear stress versus shear rate plot indicates that the rice–blackgram batter exhibited non-Newtonian fluid behavior (shear thinning property) even after 100% replacement of white rice with brown rice. The rheological characteristics of rice–blackgram batters fitted reasonably well in Cassan (r2 = 0.8521–0.9856) and power law (r2 = 0.8042–0.9823) models. Brown rice replacement at all levels did not affect the flow behavior index, yield stress, consistency coefficient, and apparent viscosity of batter at 25 ℃. However, at higher temperature, the viscosity was greater for T4 and T5 (no difference between them) than T1, T2, and T3 (no difference between them) batters. Further research is required to determine the sensory attributes and acceptability of the cooked products with brown rice-blended batter.
A strain of acidogenic bacterium was isolated from the fermentation liquid of Cantonese-style rice vinegar produced by traditional surface fermentation. 16S rDNA identification confirmed the bacterium as Gluconacetobacter xylinus, which synthesizes bacterial cellulose, and the acid productivity of the strain was investigated. In the study, the effects of the membrane integrity and the comparison of the air–liquid interface membrane with immerged membrane on total acidity, cellulose production, alcohol dehydrogenase (ADH) activity and number of bacteria were investigated. The cellulose membrane and the bacteria were observed under SEM for discussing their relationship. The correlations between oxygen consumption and total acid production rate were compared in surface and shake flask fermentation. The results showed the average acid productivity of the strain was 0.02 g/(100 mL/h), and the integrity of cellulose membrane in surface fermentation had an important effect on total acidity and cellulose production. With a higher membrane integrity, the total acidity after 144 h of fermentation was 3.75 g/100 mL, and the cellulose production was 1.71 g/100 mL after 360 h of fermentation. However, when the membrane was crushed by mechanical force, the total acidity and the cellulose production were as low as 0.36 g/100 mL and 0.14 g/100 mL, respectively. When the cellulose membrane was forced under the surface of fermentation liquid, the total acid production rate was extremely low, but the activity of ADH in the cellulose membrane was basically the same with the one above the liquid surface. The bacteria were mainly distributed in the cellulose membrane during the fermentation. The bacterial counts in surface fermentation were more than in the shake flask fermentation and G. xylinus consumed the substrate faster in surface fermentation than in shake flask fermentation. The oxygen consumption rate and total acid production rate of surface fermentation were respectively 26.13 times and 2.92 times that of shake flask fermentation.
Gelatin was extracted from the skin of tilapia (Oreochromis urolepis hornorum) and its microbiological, rheological and structural properties were characterized. The tilapia skin gelatin presented typical molecular weight distribution of type I collagen with contents of imino acids (proline + hydroxyproline) of 21.67%. Gel strength and viscosity values were 221 ± 5.68 g and 5.98 ± 0.34 cP, respectively, with the maturation time of 18 ± 1 h, and both parameters increased with the maturation time. Melting and gelling points of 25 ℃ and 21 ℃, respectively, were obtained for tilapia skin gelatin. The gelatin presented microbiological standards in accordance with the Brazilian Legislation.
One of the possibilities of using high-pressure technique in inactivation of microorganism is conducting this process at subzero temperature. However, for its practical application in meat preservation the appropriate properties of meat should be maintained. Therefore, the aim of this work was to examine the effect of pressure at subzero temperature (without freezing of water) on proteins and texture of mammal’s and cold-adapted fish meat. The data showed that cod and salmon meat proteins were more susceptible to pressure-induced denaturation/aggregation than beef and pork proteins. Glucose and saccharose exerted protective effect on fish meat proteins treated with pressure of 111 MPatc and –10 ℃ but not at 193 MPatc and –20 ℃. The pressure treatment under the latter conditions increased cook loss of fish meat but not of mammal’s meat. However, after cooking the hardness of all kinds of pressurized meat was at the same level as that for unpressurized cooked samples.
Fish is rich in polyunsaturated fatty acids with beneficial effects on human health; however, these lipids are very sensitive to auto-oxidation reactions, leading to loss of nutritional and sensory quality. The effect of traditional (brining, smoking) and novel (addition of polyphenolic extracts, high pressure) preservation processes on the antioxidant/oxidative status of muscle lipids from dolphinfish and sardine was studied. Brining with oregano or rosemary aqueous extracts, as well as smoking, gave rise to deposition of phenolic compounds (9–42, 1.5–4.5 and 0.4–2.3 µg phenol/g for smoked, oregano-brined and rosemary-brined samples, respectively) in the muscle of both fish species. The antioxidant activity, as measured by ferric reducing ability, was also improved after brining with antioxidant extracts or smoking, results ranging from 8.9 to 82 mM FeSO4 · 7H2O equivalents/mg muscle depending on the treatment and the fish species. Consequently, fish lipid oxidation (as measured by thiobarbituric acid reactive substances) derived from brining and pressurizing, applied alone or in combination, was reduced between 6.6 and 69.8% depending on the treatment and the fish species. The combination of brining with oregano extract and light smoking showed an additional antioxidant effect, as compared with that obtained by smoking, on reducing sardine lipid oxidation derived from brining and pressurizing.
Milk fat globule membrane (MFGM), due to its specific nature and composition, is known as material possessing advantageous nutritional as well as technological properties. In this study MFGM materials were produced from several dairy sources such as buttermilk (BM), butter serum (BS) and buttermilk whey (BMW) by microfiltration (MF). The obtained materials, depending on the sources, were called BM-MFGM, BS-MFGM and BMW-MFGM, respectively. The compositions of starting materials and the isolated MFGM materials as well as their emulsifying properties were analyzed and compared. As expected, the MF resulted in enrichment of polar lipids (PLs), major components of MFGM. On dry matter basis, BM-MFGM and BS-MFGM were about 2.5 times higher in PLs compared to their beginning materials while BMW-MFGM was about 8.3 times compared to buttermilk powder (BMP). Sodium dodecyl sulfate polyacrylamide gel electrophoresis showed that the microfiltered products still contained a high amount of non-MFGM proteins such as caseins, β-lactoglobulin, and α-lactalbumin. Emulsions of 35% soya oil in water were prepared with the mentioned materials using a homogenizer at various pressures. Generally, emulsions prepared with BMP and butter serum powder had significantly higher particle sizes than those prepared with the MFGM materials. This result along with microscopy observation and viscosity measurement indicated the presence of aggregated particles in the former emulsions, probably as a result of lack of surface-active components. The differences in composition, especially in content of PLs and proteins of the materials were the main reasons for the differences in their emulsifying behaviors.
There has been recently increased interest in sorghum to substitute the gluten containing cereals in the diet of people suffering from celiac disease. The response surface methodology was used to determine the influence of malting parameters (degree of steeping, germination temperature and time) on sorghum (Sorghum bicolor (L.) Moench). Each parameter was varied at three levels. Malting attributes, considered important to produce high quality malt for the production of lactic acid fermented beverages, were analyzed. The optimized conditions were: degree of steeping 41%, germination temperature 27℃ after 7 days of germination. Under these conditions, the following values of the studied attributes can be obtained: α-amylase 139 U/g, β-amylase 60 U/g, extract 83.8%, free amino nitrogen 117.8 mg/100 g, Kolbach index 26.6%, water-extractable arabinoxylan 0.3 g/L and vitamin B2 114.9 µg/L. Among the tested parameters, the germination time had the highest effect on malting attributes. Although the activity of amylolytic enzymes α- and β-amylase were low, the value of extract was high and comparable to that of barley malt. The obtained results showed that sorghum malt is a promising raw material for the production of lactic acid fermented beverages.
This study was conducted to investigate the effect of air temperature and air flow velocity on kinetics of color parameter changes during hot-air drying of green tea, to obtain the best model for hot-air drying of green tea, to apply a computer vision system and to study the color changes during drying. In the proposed computer vision system system, at first RGB values of the images were converted into XYZ values and then to Commission International d’Eclairage L*a*b* color coordinates. The obtained color parameters of L*, a* and b* were calibrated with Hunter-Lab colorimeter. These values were also used for calculation of the color difference, chroma, hue angle and browning index. The values of L* and b* decreased, while the values of a* and color difference (E*ab) increased during hot-air drying. Drying data were fitted to three kinetic models. Zero, first-order and fractional conversion models were utilized to describe the color changes of green tea. The suitability of fitness was determined using the coefficient of determination (R2) and root-mean-square error. Results showed that the fraction conversion model had more acceptable fitness than the other two models in most of color parameters.
In the present study, the influence of moisture content, temperature and time during heat treatment of wheat flour was investigated. Heat treatment was carried out on laboratory scale in a water bath at 50–90 ℃ for times up to 3 h. Flour functionality was evaluated by analysing protein solubility in acetic acid as well as by the formation of bread-like doughs, which were then analysed with dynamic oscillatory and rotational rheometry. Effects during heat treatment were explained on a molecular level using a simplified physical model describing wheat dough as a continuous gluten matrix with starch as filler particles. Heat treatment causes the formation of gluten aggregates resulting in decreased protein solubility and lower network strength of dough. Rheological data also indicate the formation of starch aggregates and modified interactions between gluten and starch. The effects were more pronounced in heat-treated flours with increased moisture content due to a higher mobility of the molecules.
Frybreads were prepared using wheat flour and wheat-sorghum composite flours (refined and whole grain; white, tannin-free and red, tannin-containing) at 0, 25, 50, and 75% sorghum flour. Hardness, volume, specific volume, color, and oil uptake were determined. Frybreads made with refined white, tannin-free sorghum were also evaluated in a sensory panel. Substitution of sorghum flour for wheat flour reduced the volume and increased the darkness of the fried dough pieces compared with wheat flour controls. Oil absorption was unaffected when using white, tannin-free sorghum. When using red, tannin-containing sorghum, oil absorption increased for refined flour and decreased for whole grain flour, suggesting that a component only present in the whole grain tannin-containing Sorghum—perhaps tannins themselves—may decrease oil uptake. Panelists rated frybreads containing up to 50% white, tannin-free sorghum flour as not significantly different from control frybreads made with refined wheat flour.
Drying characteristics of broccoli was experimentally studied in cabinet-type convective dryer. Experiments were conducted using constant air velocity of 2 m/s and air temperature of 60 ℃. Drying rate increased with increasing blanching temperature and thus reduced the drying time. The experimental drying data were used to fit twelve drying models and drying rate constants and coefficients of the models were determined by non-linear regression analysis. Estimations by the Midilli et al. model were in good agreement with the experimental data obtained. Fick’s second law was used to calculate the effective moisture diffusivity, which varied from 1.987 to 3.577 x 10-8 m2/s for the given blanching temperature range. The rehydration ratio was observed to increase with increasing blanching temperature.
The combined effect of natural antioxidants and packaging materials on the quality decay of breakfast cereals during storage was evaluated. Corn flakes were produced on industrial scale, using different packages and adding natural tocopherols to the ingredients, and stored for 1 year. The samples were then submitted to sensory analysis and HS-solid phase microextraction/gas chromatography/mass spectrometry (SPME/GC/MS) analysis. The packaging had a significant influence on the sensory profile of the aged product: metallized polypropylene gave the highest levels of oxidation compounds and sensory defects. The sensory profile was improved using polypropylene and especially high-density polyethylene. Natural tocopherols reduced the sensory decay of the flakes and the oxidative evolution of the volatile profile. They gave the most remarkable improvement in polypropylene (either metallized or not) packs. Polypropylene showed a barrier effect on the scalping of volatiles outside of the pack. This led to higher levels of oxidation volatiles and faster rates of the further oxidative processes involving the volatiles.
The formation of soluble melanoidins from a single combination of sugar (fructose) and amino acid model systems were evaluated kinetically. The selected amino acids, commonly found in apple juice and highly reactive in the Maillard reaction, were asparagine, aspartic acid, and glutamic acid. The effect of these reagents and the treatment at different temperatures (50 ℃, 85 ℃, and 100 ℃) during 96 h on the color intensity of the melanoidin formed was measured by absorbance at different wavelengths (280, 325, 405, and 420 nm). The absorbance of the melanoidin formed from all model systems was located on the wavelength of 405 nm, that is, the area of the visible spectrum close to the UV region. The color of the melanoidins was directly measured using the CIELAB color space system. A first-order kinetic model was applied to the evolution of the E* (color difference) and L* (lightness) of the color. The fructose/aspartic acid model system values of a* (redness) and b* (yellowness) were found in the brown-red zone. Therefore, the color development of the melanoidins was influenced by the type of amino acid and temperature. Especially, it is thought that the a* and b* values can be used to explain the differences among the amino acids in the color development of melanoidins.
Instant noodles were prepared from fifteen diverse wheat cultivars varying widely in their flour quality and dough rheology. Dough thermomechanical parameters obtained by Mixolab and flour analytical properties were correlated with the quality of instant noodles including oil uptake, cooking quality and textural attributes. The Mixolab parameters dough development time and dough stability showed significant positive correlation with cooking time, cooked weight, overall acceptability, hardness, springiness, cohesiveness and chewiness of noodles, while negatively correlated with oil uptake and cooking loss, therefore, exhibiting a marked positive effect on quality of instant noodles. Lower protein breakdown represented by C2 torque was also positively related with overall acceptability, hardness, springiness, cohesiveness and chewiness of noodles. Stickiness/adhesiveness of noodles was revealed to be mainly conferred by falling number values (R2 = 0.671) and damaged starch (R2 = 0.523) content of wheat flour samples. Flour samples with lesser values of protein content, sodium dodecyl sulphate sedimentation volume, thermal stability of proteins, dough stability and dough development time were found to be linked with poor noodle quality. Medium strong flours performed better in noodle making, while weaker flours demonstrated poor noodle quality. Dough rheology of good noodle making flours was characterized with higher dough development time, dough stability, C2, C3, C4 as well as C5 values. Noodles with higher overall acceptability showed a more continuous and uniform protein starch matrix in comparison to the poor counterparts.
In this study, the effects of ohmic pre-drying technique on moisture ratio, drying rate, drying time, specific energy consumption, drying efficiency, and effective moisture diffusivity of tomato paste were investigated. Pre-drying experiments were carried out in an ohmic laboratory dryer at voltage gradient levels of 6, 8, 10, 12, 14, and 16 V/cm and oven at 105 ℃ and 1.0 m/s air velocity (control sample). Pre-drying was accomplished till the moisture content of the tomato paste reduced from initial moisture content of 90% (w.b.) to a safer level of 70% (w.b.). The ohmic pre-drying reduced the drying time of tomato paste by 80–97%, compared with the hot air drying. Pre-drying took place mainly in warming up, constant rate, and falling rate periods. Six available moisture-ratio models were fitted to the pre-drying data. The results showed that the Midilli et al. model is the most appropriate model for pre-drying behavior of tomato paste. The effective moisture diffusivity varied from 5.39 x 10–8 to 3.91 x 10–7m2/s with an activation energy of 2.082 (V/g.cm). Both specific energy consumption and drying efficiency were considerably enhanced by increasing voltage gradient. It was found that the specific energy consumption and drying efficiency varied from 3.72 to 2.29 MJ/kg water and 67.8 to 83.8%, respectively.
Most of the commercialized lactic acid fermented products are dairy-based. Hence, the development of non-dairy fermented products with probiotic properties draws significant attention within the functional foods industry. The microorganisms used in such products have complex enzyme systems through which they generate diverse metabolites (volatile and non-volatile) that provide significant flavour attributes of importance for fermented foods. The correlation of the volatile flavour compounds of a malt beverage fermented with a Bifidobacterium breve strain with its unique sensory characteristics was performed. The volatile composition analysis exposed the presence of 12 components. Eight of these flavour volatiles were produced through the metabolic activity of the bifidobacteria strain. Notably acetic acid, of reported sour flavour characteristics, exhibited the greatest intensity. Four components of considerable organoleptic characteristics were identified as Maillard-derived products, namely maltol, pyranone, 2 (5H)-furanmethanol and 3-furanmethanol. The sensory evaluation exhibited that the fermented cereal beverage had a sour flavour with mild sweet and malty notes. These results indicate that the volatile compounds identified can be appointed as significant flavour markers of the novel fermented cereal beverage.
Papaya fruits (Carica papaya L. cv ‘Sui you 2’) harvested with <5% yellow surface at the blossom end were fumigated with 60 µL/L of nitric oxide for 3 h and then stored at 20 ℃ with 85% relative humility for 20 days. The effects of nitric oxide treatment on ethylene production rate, the activities of cell wall softening related enzymes including polygalacturonase, pectin methyl esterase, pectate lyase and cellulase and the levels of hormones including indole acetic acid, abscisic acid, gibberellin and zeatin riboside were examined. The results showed that papaya fruits treated with nitric oxide had a significantly lower rate of ethylene production and a lesser loss of firmness during storage. A decrease in polygalacturonase, pectin methyl esterase, pectate lyase and cellulase activities was observed in nitric oxide treated fruit. In addition, the contents of indole acetic acid, abscisic acid and zeatin riboside were reduced in nitric oxide treated fruit, but no significant reduction in the level of gibberellin was found. These results indicate that nitric oxide treatment can effectively delay the softening and ripening of papaya fruit, likely via the regulation of cell wall softening related enzymes and certain hormones.
In the food industry, osmotic dehydration can be an important stage to obtain partially dry foodstuffs. However, the remaining spent osmotic solution at the end of the process could become a waste with an important environmental impact due to the large amount of organic compounds that it might contain. Since one of the most important osmotic agents used in osmotic dehydration is sucrose, this spent osmotic solution could be used to be biotransformed to produce fructooligosaccharides by a fructosyltransferase. This study evaluated the production of fructooligosaccharides using the fructosyltransferase produced by Aspergillus oryzae N74, and the spent osmotic solution that resulted in the osmotic dehydration of Andes berry (Rubus glaucus) and tamarillo (Cyphomandra betacea). Assays were conducted at small and bioreactor scales, using spent osmotic solution with or without re-concentration. At small scale no significant difference (p > 0.05) was observed in the fructooligosaccharides production yield, ranging from 31.18% to 34.98% for spent osmotic solution from tamarillo osmotic dehydration, and from 33.16% to 37.52% for spent osmotic solution from Andes berry osmotic dehydration, using either the SOS with or without re-concentration. At bioreactor scale the highest fructooligosaccharides yield of 58.51 ± 1.73% was obtained with spent osmotic solution that resulted from tamarillo osmotic dehydration. With the spent osmotic solution from Andes berry osmotic dehydration the yield was 49.17 ± 2.82%. These results showed the feasibility of producing fructooligosaccharides from spent osmotic solution that is considered a waste in food industry.
In this study, the moisture sorption isotherm of osmotically dehydrated mackerel fillets (Scomber japonicus) was experimentally determined. The fillets were osmotically dehydrated with solutions of salt (NaCl) (120 and 180 g per liter of solution) or in combination with sugar (350 to 700 g per liter of solution). The sorption isotherms were determined using the static gravimetric methodology with six salts for the water activity range of 0.33–0.98 at 5 ℃ and 25 ℃. All the sorption curves were found to be type III. Temperature and the final tissue salt content had significant (p < 0.05) effects on the sorption isotherms. A regression program was used to fit the Halsey, Oswin and Smith moisture sorption isotherm models. Oswin equation gave the best fit for the whole range of water activity and temperatures. The Smith equation only presented valuable results for the mackerel fillets samples with the higher salt content.
The technological and sensory quality of pasta made from bread wheat flour substituted with wholemeal amaranth flour (Amaranthus mantegazzianus) at four levels, 15, 30, 40 and 50% w/w was investigated. The quality of the resulted pasta was compared to that of control pasta made from bread wheat flour. The flours were analyzed for chemical composition and pasting properties. Cooking behavior, color, raw and cooked pasta texture, scanning electron microscopy and sensory evaluation were determined on samples. The pasta obtained from amaranth flour showed some detriment of the technological and sensory quality. So, a maximum substitution level of 30% w/w was defined. This is an equilibrium point between an acceptable pasta quality and the improved nutritional and functional properties from the incorporation of amaranth flour.
Peel pitting is a disorder occurring mostly during postharvest storage at non-chilling temperatures in different varieties of citrus fruit and consists in collapse of flavedo and albedo tissues that may affect oil glands. It has been demonstrated that during postharvest, sharp variations in water potential of cells from flavedo and albedo are sufficient to provoke fractures in cell walls from external albedo resulting in tissue collapse. However, morphology and composition of cells and cell walls in flavedo and albedo varies during fruit maturation and this may affect water flow through the different fruit peel layers and susceptibility of fruit to develop peel pitting. In this paper, we have studied the influence of the stage of maturation in the susceptibility of Navelina orange to develop peel pitting. Except in mature-green fruit, peel pitting increased with maturation after transferring fruit from 45% to 95% relative humidity and was also more severe as more dehydrated was the tissue before transference. Also, differences in water potential of fruit maintained at 45 or 95% relative humidity increased as fruit matured, suggesting that tissue reduces the ability of water adjustment during maturation. In this sense, only mature-green fruit flavedo was able to recover water potential when transferred from 45 to 95% relative humidity. Ethylene production upon transfer from low to high relative humidity increased only in mature tissue and was rapid and transient, and before initial symptoms of peel pitting. Flavedo and albedo water potential (w) was substantially reduced during fruit maturation. As lower was the w of freshly harvested fruit, minor variations were observed by changes in the storage relative humidity and higher the induced damage. Therefore, the increasing susceptibility of Navelina fruits to develop peel pitting with fruit maturation may be related to a reduced ability to regulate peel evapotranspiration and osmotic adjustment during postharvest storage.
The effects of different washing solutions and packaging films on textural, biochemical and microbial quality of green slender peppers (Capsicum annuum L.) were evaluated. Fresh pepper samples were packaged either in 35 µm polypropylene or polyethylene bag without washing or after washing in tap water (TW), 100-ppm chlorine solution, 0.5% calcinated calcium solution followed by 25% ethanol rinsing (CC+E) and 1% citric acid solution followed by 50% ethanol spray (CA+E) and then stored at 10 ℃ for 4 weeks. Significant differences were found in gas composition between the two packaging films. Changes in skin puncture force, hue angle, soluble solid content, titratable acidity and pH were statistically insignificant. Chlorophyll a, chlorophyll b and total chlorophyll content declined significantly (P < 0.05) in all treatments during storage. Significant reduction (P < 0.05) in aerobic plate count was found in all washing treatments compared to unwashed sample except in TW. Yeast and mold count of chlorine and CC+E-treated samples were lower than other treatments. Samples of these two treatments also received marketable limit of visual quality scores until 4 weeks of storage in polypropylene film. Results suggest that CC+E could be a potential sanitizer and alternative to chlorine washing and polypropylene film would provide a little better advantage than polyethylene for green slender pepper.
Jumbo squid is an important fishery resource in Mexico, and its muscle is lean and white and it has a very low price in the market. It is abundant, but with little or nothing added value, therefore is necessary to search alternatives of processing. Due to muscle characteristics, the aim of this study was to obtain protein concentrates using different methods. They were obtained by means of acidic (acid protein concentrates) and alkaline (alkaline protein concentrates) dissolution. Moreover, a protein concentrate was obtained by direct isoelectric precipitation and by the traditional method (neutral protein concentrates). The yield with better results was alkaline protein concentrates (63.58 ± 1.8%). The gel hardness was significantly different (p < 0.05), especially for the alkaline protein concentrates. The acid protein concentrates, isoelectric precipitation and alkaline protein concentrates were better with regard to the neutral protein concentrates, concerning the emulsifying and foaming properties. The protein concentrates by means of alkaline dissolution gave a better gelling property, but all the processes had the potential to obtain protein with emulsifying and foaming properties.
The fresh-cut industry is constantly growing and generating wastes. The major challenge for this industry consists in an environmentally sustainable production through re-utilization of by-products, for instance, in extraction of bioactive compounds. In this paper, the nutritional and functional compounds of apple, potato, cucumber, melon and watermelon by-products were investigated. The amount of by-product produced was of 10.10 to 30.80% of initial fresh weight depending on the product. By-products were characterized by low protein (<20 g/kg fresh weight) and fatty acid content (<5 g/kg fresh weight) and high levels of minerals. Carbohydrates content ranged from 43.7 to 235 g/kg fresh weight, while total dietary fibre was between 20 and 150 g/kg fresh weight The content of antioxidants (53.6 to 3453.2 mg/kg fresh weight) and total polyphenols (124.5 to 4250.2 mg/kg fresh weight) depended strongly on the type of by-product. In most cases, the nutritional and bioactive content was higher in the peel than in whole product. Apple peel was rich in carbohydrates, total dietary fibre, antioxidants and total polyphenols. Potato peel was high in iron. Melon was rich in magnesium. Watermelon peel was characterized by the level of potassium, and cucumber peel was rich in manganese, zinc, phosphorous, calcium and sodium. All these data demonstrate than natural by-product from fresh-cut industry could potentially be utilized as ingredients to design new functional foods with a future market.
Soy protein isolate is typical vegetable protein with health-enhancing activities. Inulin, a prebiotic no digestible carbohydrate, has functional properties. A mashed potato serving of 200 g with added soy protein isolate and/or inulin concentrations of 15–60 g kg–1 provides from 3 to 12 g of soy protein isolate and/or inulin, respectively. Currently, no information is available about the possible texture-modifying effect of this non-ionizable polar carbohydrate in different soy-based food systems. In this study, the effect of the addition of soy protein isolate and inulin blends at different soy protein isolate: inulin ratios on the degree of inulin polymerization and the rheological and structural properties of fresh mashed and frozen/thawed mashed potatoes were evaluated. The inulin chemical structure remained intact throughout the various treatments, and soy protein isolate did not affect inulin composition being a protein compatible with this fructan. Small-strain rheology showed that both ingredients behaved like soft fillers. In the frozen/thawed mashed potatoes samples, addition of 30 : 30 and 15 : 60 blend ratios significantly increased elasticity (G' value) compared with 0 : 0 control, consequently reducing the freeze/thaw stability conferred by the cryoprotectants. Inulin crystallites caused a significant strengthening effect on soy protein isolate gel. Micrographs revealed that soy protein isolate supports the inulin structure by building up a second fine-stranded network. Thereby, possibility of using soy protein isolate and inulin in combination with mashed potatoes to provide a highly nutritious and healthy product is promising.
Polyphenolic-rich antioxidant extracts from native plants have potential applications as ingredients in functional foods; however, their intense characteristic flavour is a major imitation to their application. In this context, the aim of the present work was to evaluate the influence of steam distillation on the sensory and physicochemical characteristics of extracts of five native Uruguayan plants (Acca sellowiana, Achyrocline satureioides, Aloysia gratisima, Baccharis trimera and Mikania guaco). Aqueous extracts from the five native plants were obtained. Steam distillation was used to produce two types of deodorized extracts: extracts from deodorized leaves and extracts deodorized after the extraction. The extracts were characterized in terms of their total polyphenolic content and antioxidant activity (using 2,2-diphenyl-1-picryl-hydrazyl and 2,2'-azino-bis(3-ethylbenzothiazoline-6-sulfonic acid methods). A trained assessor panel evaluated characteristic odour, characteristic flavour, bitterness and astringency of the extracts. The total polyphenolic content of the extracts ranged from 112.4 to 974.4 mg/100 mL, whereas their antioxidant capacity ranged from 9.6 to 1008.7 mg vitamin C equivalents/100 mL, depending on the type of extract and the method being considered. Steam distillation was effective in reducing the characteristic odour and flavour of the extracts, without causing large changes in their polyphenolic content and antioxidant activity. In general, in terms of sensory characteristics, steam distillation performed on the extracts gave better results than when performed on the leaves; whereas the opposite trend was found for polyphenolic content and antioxidant activity. Results suggested that steam distillation could be a promising low-cost procedure for the production of antioxidant extracts for food products.
The influence of hot water dips (50, 52 and 54 ℃ for 3 min) on fruit quality, phenolic compounds and antioxidant capacity of Satsuma mandarin during 60 days’ storage at 10 ℃ was investigated. Hot water dips did not affect fruit quality attributes as well as ascorbic acid content, and 50 ℃ treatment significantly reduced fruit weight loss. Significant increases of flavonoids were found in all hot water treated fruit from after treatments till 15 days of storage, whereas phenolic acids were not greatly affected. Hot water dipping at 50 ℃ significantly increased total phenolics and antioxidant capacity of Satsuma mandarin immediately after treatment and maintained similar levels with control during storage, while 52 and 54 ℃ treatments showed relatively lower levels. The results suggested that hot water dipping at 50 ℃ for 3 min can be a promising way to retain functional quality of storing Satsuma mandarin.
Previous results showed that an indigenously isolated yeast strain of Candida tropicalis was found to produce 12.11 gl–1 of xylitol under unoptimized conditions in presence of 50 gl–1 of xylose. In the present study, optimizing the process using one-variable at-a-time resulted in the production of 59.07 gl–1 of xylitol in 96 h in presence of 100 gl–1 xylose. Further optimization using response surface methodology led to the production of 65.45 gl–1 in medium containing 100 gl–1 xylose, 0.5% yeast extract, 0.03% MgSO4.7H2O and 0.2% KH2PO4, pH-4.5, 30 ℃, 200 r/min for 96 h with 4% inoculum level. Addition of 1% methanol in response surface methodology optimized–medium led to the production of 67.12 gl–1. Scaling up in 10 L fermentor resulted in productivity of 0.80 g/lh–1 with yield of 0.68 gg–1. Efficient synthesis of xylitol esters was achieved with butyric acid (50.32%) and caproic acid (38.36%) in 4 h using Pseudomonas aeruginosa lipase in t-butanol: tetrahydrofuran (1:1 v/v).
Extensive research has revealed numerous nutritional and health benefits of flaxseed due primarily to its nutrients content. The objective of this study was to evaluate the effect of flaxseed flour addition on the physical and sensory characteristics of cereal bars. Four formulations of the flaxseed cereal bars were prepared by partially replacing oats with flaxseed flour added at levels of 0 (control), 6%, 12% and 18%. There were no significant differences (p > 0.05) in water activity, moisture and firmness values between the flaxseed bars and control. Flaxseed addition significantly (p < 0.05) decreased lightness and increased redness of the bars. There were no significant differences (p > 0.05) between the 12% flax cereal bars and the control with respect to sensory attributes and overall acceptability. The overall acceptability for both 12% flax bars and the control was in between ‘like moderately’ and ‘like slightly’ on the 9-point hedonic scale. The overall acceptability was most highly correlated with flavor acceptability for both control (r = 0.80) and 12% flax (r = 0.82) cereal bars. Flaxseed bars provided 12% dietary fiber of the daily recommended value. These results indicated that flaxseed flour incorporation up to 12% substantially enhanced the nutritional qualities of the cereal bars without affecting their sensory and quality properties.
The growth interactions between Geotrichum candidum and Lactobacillus rhamnosus GG were studied in milk. The effect of temperature on the growth rate of the fungus was modelled using the cardinal temperature model with inflection. The secondary modelling was applied also on the other data set containing the growth rates of G. candidum in co-culture with a commercial starter culture. The low temperature in combination with L. rhamnosus GG in co-culture showed the most negative effect on the growth rate of G. candidum. On the other hand, neither L. rhamnosus GG nor the starter culture had significant effect on the optimum and maximum temperature parameters calculated for growth of G. candidum. Their values ranged from 28.9 ℃ to 31.3 ℃ and 35.3 ℃ to 37.3 ℃, respectively. The quantitative data presented in the study showed a non-specific effect of lactic acid bacteria on the growth rate of G. candidum observed mainly around the optimal temperature.
The objectives of this study were to introduce alternative methods in the process of pectin extraction from quince pomace, to determine the effect of selected process variables (factors) on the obtained pectin, and to perform a preliminary optimization of the process. A fractional factorial experimental design was applied, where the factors considered were six: quince pomace pretreatment (washing vs blanching), drying method (hot air vs LPSSD), acid extraction condictions (pH, temperature, and time), and pectin extract concentration method (vacuum evaporation vs ultrafiltration). The effects of these factors and their interactions on pectin yield (Y: 0.2–34.2 mg/g), GalA content (44.5–76.2%), and DM (47.5–90.9%), were determined. For these three responses, extraction pH was the main effect, but it was involved in two and three factors interactions. Regarding alternative methods, LPSSD was required for maximum Y and GalA, and ultrafiltration for maximum GalA and DM. Response models were used to predict optimum process conditions (quince blanching, pomace drying by LPSSD, acid extraction at pH 2.20, 80 ℃, 3 h, and concentration under vacuum) to simultaneously maximize Y (25.2 mg/g), GalA (66.3%), and DM (66.4%).
Defatted soybean meal, a by-product of soybean oil extraction, was pretreated by ultrasonic and hydrolyzed with neutrase. The DSMH pretreated at 400 W of ultrasonic power, identified to possess the strongest antioxidant activity, was fractionated according to molecular weight into three fractions of DSMH-I (>10 kDa), DSMH-II (5–10 kDa), and DSMH-III (<5 kDa) using ultrafiltration. The fraction, DSMH-III (<5 kDa), exhibited the highest antioxidative activity and was further purified using ion-exchange chromatography. The DSMH-III was separated into five fractions (A, B, C, D, and E). Fraction C with molecular weight of 2434 Da exhibited the strongest free radical scavenging, which was evidenced by the electron spin resonance of 1,1-diphenyl-2-pycryl hydrazyl and hydroxyl radicals. Fraction C was subjected to reverse-phase high performance liquid chromatography and the sequences of the highest activity peptide were determined by liquid chromatography tandem mass spectrometry. The strongest antioxidant activity peptide had the amino acid sequence of Glu–Glu–Gln–Glu–Trp–Pro–Arg–Lys–Glu–Glu–Lys. In conclusion, ultrasonic treatment and ultrafiltration could enhanced antioxidant activity of DSMH.
Wine grape pomace dietary fiber powders were prepared by superfine grinding, whose effects were investigated on the composition, functional and antioxidant properties of the wine grape pomace dietary fiber products. The results showed that superfine grinding could effectively pulverize the fiber particles to submicron scale. As particle size decrease, the functional properties (water-holding capacity, water-retention capacity, swelling capacity, oil-binding capacity, and nitrite ion absorption capacity) of wine grape pomace dietary fiber were significantly (p < 0.05) decreased and a redistribution of fiber components from insoluble to soluble fractions was observed. The antioxidant activities of wine grape pomace and dietary fiber before and after grinding were in terms of DPPH radical scavenging activity, ABTS diammonium salt radical scavenging activity, ferric reducing antioxidant power, and total phenolic content. Compared with dietary fiber before and after grinding, micronized insoluble dietary fiber showed increased ABTS radical scavenging activity, ferric reducing antioxidant power, and total phenolic content yet decreased DPPH radical scavenging activity. Positive correlations were detected between ABTS radical scavenging activity, ferric reducing antioxidant power, and total phenolic content.
The drying kinetics of thyme was analyzed by considering different conditions: air temperature of between 40 ℃ and 70 ℃, and air velocity of 1 m/s. A theoretical diffusion model and eight different empirical models were fitted to the experimental data. From the theoretical model application, the effective diffusivity per unit area of the thyme was estimated (between 3.68 x 10–5 and 2.12 x 10 –4 s–1). The temperature dependence of the effective diffusivity was described by the Arrhenius relationship with activation energy of 49.42 kJ/mol. Eight different empirical models were fitted to the experimental data. Additionally, the dependence of the parameters of each model on the drying temperature was determined, obtaining equations that allow estimating the evolution of the moisture content at any temperature in the established range. Furthermore, artificial neural networks were developed and compared with the theoretical and empirical models using the percentage of the relative errors and the explained variance. The artificial neural networks were found to be more accurate predictors of moisture evolution with VAR ≥ 99.3% and ER ≤ 8.7%.
The effect of seasonal changes (summer versus winter) upon the quality of heat-induced gel products from farmed sea bass (Dicentrarchus labrax) was studied. Moreover, the effect of microbial transglutaminase addition (0.5%, w/w) on the quality was assessed. Fat content of gel products attained from sea bass grown during summer was higher (12.0% versus 7.6%). Textural properties of the gels from the summer fish were higher. Protein of gels from winter fish was less soluble in SDS + DTT (sodium dodecyl sulphate, SDS; dithiothreitol, DTT). Contrary to some literature, higher fat level may have played a protective role during processing. Accordingly, season via fat content variation had a strong effect on the gelling ability of heat-induced gels prepared from sea bass.
The use of coatings is a technique used to increase postharvest life of the fruit. Almond gum exudate was used, in comparison with gum arabic, at concentrations of 10% as a novel edible coating, to preserve the quality parameters of tomato (Solanumlycopersicum). Fruits were harvested at the mature-green stage of ripening. Results showed that the coatings delayed significantly (p < 0.05) the changes in color, weight loss, firmness, titratable acidity, ascorbic acid content, soluble solids concentration, and decay percentage compared to uncoated control fruits. Sensory evaluation proved the efficacy of 10% almond gum and gum arabic coatings to maintain the overall quality of tomato fruits during storage period (20 days). In addition, the difference between gum arabic and almond gum coatings was not significant (p > 0.05) except for pulp color. Therefore, we can suggest the use of almond gum exudate as a novel edible coating extends the shelf-life of tomato fruits on postharvest.
Soybean flakes were extracted using supercritical carbon dioxide at 48.3 MPa and 80 ℃, which is a higher temperature than previously reported. Several operational parameters were explored to determine their effect on extractions. Flakes, as typically used in this industry, provided the best extraction performance. Particle size distributions were created through grinding. Reducing average particle diameters smaller than 0.069 mm had no appreciable effect on increasing extraction efficiencies. Exploration of flow rate indicated that a residence time of less than 60 s for the supercritical carbon dioxide would be sufficient for complete extractions. A solvent mass to load mass ratio of 10:1 was found to be sufficient for extraction of oils from soybean flakes. Increasing moisture in the soybeans led to decreasing extraction efficiency of oils. Finally, soybean hulls had no effect on extraction efficiency. Thus, the de-hulling procedure can be removed from the extraction process without decreasing extraction efficiency.
The effect of gamma irradiation (0–2 kGy) and storage time (0–28 days) on microbial growth and physicochemical characteristics of a packed pumpkin puree was studied. For that purpose, a factorial design was applied. The puree contained potassium sorbate, glucose and vanillin was stored at 25 ℃. Gamma irradiation diminished and storage time increased microbial growth. A synergistic effect between both variables on microbial growth was observed. Storage time decreased pH and color of purees. Sorbate content decreased with storage time and gamma irradiation. Mathematical models of microbial growth generated by the factorial design allowed estimating that a puree absorbing 1.63 kGy would have a shelf-life of 4 days. In order to improve this time, some changes in the applied hurdles were assayed. These included a thermal treatment before irradiation, a reduction of irradiation dose to 0.75 kGy and a decrease in storage temperature at 20 ℃. As a result, the shelf-life of purees increased to 28 days.
The objective of this work was to study the effect of post-packaging pasteurization on the sensory quality and growth of natural microorganisms during refrigerated storage (6 ℃) of a cooked meat product considering two packaging atmospheres based on mixture of typical gases (CO2/N2 (22/78%) and novel gases (CO2/Ar (17/83%)). Growth of lactic acid bacteria was significantly different between samples with and without post-packaging pasteurization, showing a growth rate >0.44 and equal to 0.28 log cfu/day, respectively. For samples with post-packaging pasteurization, atmosphere CO2/Ar resulted in a lower growth of lactic acid bacteria and a better sensory quality. Overall, samples without post-packaging pasteurization did not show a significant reduction of sensory quality during storage time (121 days) while samples with post-packaging pasteurization showed deterioration in their sensory quality. Further investigation is needed to obtain more definitive conclusions about the effect of post-packaging pasteurization and argon-based packaging atmospheres on cooked meat products.
The effect of grape seed and green tea extracts was compared with effect of sodium ascorbate on bacterial spoilage, lipid stability and sensory quality in cooked pork meatballs during refrigerated storage. Meatballs were stored at 4 ℃ in aerobic packaging for 0, 4, 8, 12 and 16 days under retail display conditions. Lipid oxidation was evaluated as thiobarbituric acid reactive substances, volatile compounds and cholesterol oxidation products. Colour stability was assessed through CIELab parameters. Microbiological spoilage was determined through total viable, mould and yeast and coliform counts. The samples containing green tea and grape seed extracts showed lower levels of thiobarbituric acid reacting substances, major volatile compounds and microbiological counts than the samples with sodium ascorbate. Formation of cholesterol oxidation products was also inhibited to a greater extent. Colour was not affected by refrigerated storage; however, the addition of extracts provided brown shades. The addition of antioxidants did not modify the sensory attributes except for the colour. Green tea and grape seed extracts were more effective than sodium ascorbate at preventing lipid oxidation.
Full-fat cheese usually contains high amounts of saturated fatty acids and cholesterol, which may have negative health effects. In this study, full-fat white brined cheese, as a control sample, and experimental cheeses with olive and canola oils (T1, white brined cheese containing 50% canola oil, T2, white brined cheese containing 50% olive oil, T3, white brined cheese containing 100% canola oil and T4, white brined cheese containing 100% olive oil) were prepared from bovine milk. Physicochemical properties, lipolysis, proteolysis patterns and sensorial properties in the prepared samples were determined during 80 days of storage at 20-day intervals. Cheese incorporating vegetable oils showed lower amounts of saturated fatty acids and higher amounts of unsaturated fatty acids compared with the full-fat cheese (control) samples. Moisture, pH, lipolysis value, as assessed by the acid-degree value, and proteolysis values (pH 4.6 SN/TN% and NPN/TN%) significantly (p < 0.05) were increased in all samples, whereas total titrable acidity decreased during 40 days of ripening but then increased slightly. Sensory properties of white brined cheese incorporating with vegetable oils were different from those of full-fat cheese samples. White brined cheese containing olive and canola oils (100% fat substitution) received better sensory scores compared to other samples. The results showed that it is possible to replace dairy fat with olive and canola oils, which can lead to produce a new healthy and functional white brined cheese.
The survival capacity of Salmonella enterica serovar Typhimurium acid adapted and non-acid adapted cells was monitored in pasteurized yogurt (pH 4.1) and orange juice (pH 3.6) during storage at different temperatures (4, 10, 25 and 37 ℃). Acid adapted and non-acid adapted cells were obtained by means of their growth for 36 h in Brain Heart Infusion broth acidified at pH 4.8 with citric acid and buffered (pH 7.0) Brain Heart Infusion broth, respectively. S. typhimurium showed a great ability to survive in both foodstuffs and, especially, in yogurt, where both acid adapted and non-acid adapted populations suffered only a reduction of about 1.3–1.9 log10 cycles after 43 days of storage in the range of temperatures 4–25 ℃. At 37 ℃ a higher bacterial inactivation was observed (4.0–4.4 log10 cycles). In orange juice, a different behaviour was observed for acid-adapted and non-acid adapted cells. Whereas non-acid adapted cells survived better than acid adapted cells at 4 and 10 ℃, acid adapted cells showed enhanced survival abilities at higher temperatures (25 and 37 ℃). Thus, the times required to achieve a 5 log10 cycles reduction for non-acid adapted and acid adapted cells were 10.2 and 6.0 (4 ℃), 6.3 and 4.2 (10 ℃), 0.6 and 1.0 (25 ℃) and 0.10 and 0.15 (37 ℃) days, respectively. Evidence found in this study demonstrates that refrigeration temperatures protect S. typhimurium from inactivation in acid foods and indicates that S. typhimurium acid tolerance response (ATR) is determined by storage temperature and food composition.
The effect of high-pressure treatment (400 or 600 MPa for 7 min) on microbiology, proteolysis, texture and sensory parameters was investigated in a mature raw goat milk cheese. At day 60 of analysis, Mesophilic aerobic, Enterobacteriaceae, lactic acid bacteria and Listeria spp. were inactivated after high-pressure treatment at 400 or 600 MPa. At day 90, mesophilic aerobic, lactic acid bacteria and Micrococacceae counts were significantly lower in high-pressure-treated cheeses than in control ones. In general, nitrogen fractions were significantly modified after high-pressure treatment on day 60 at 600 MPa compared with control cheeses, but this effect was not found in cheeses after 30 days of storage (day 90). On the other hand, high-pressure treatment caused a significant increase of some texture parameters. However, sensory analysis showed that neither trained panellists nor consumers found significant differences between control and high-pressure-treated cheeses.
Physicochemical properties of wheat grains with largest kernel thickness always was lowest than the other sections, examination of microstructure of wheat grains can help us understand this phenomena. Two varieties of wheat, soft white winter wheat Yangmai 11 and hard white winter wheat Zhengmai 9023, were fractionated into five sections by kernel thickness. Then the fractionated wheat grains in 2.7–3.0 mm section were separated into three fractions by kernel specific density sequentially. Microstructure of the fractured surface were evaluated at different scale level to two varieties wheat with different kernel thickness and specific density by using environmental scanning electron microscopy. Compactness and size of endosperm cell tended to decrease with decreasing wheat kernel thickness and specific density. Protein matrix tended to increase with decreasing wheat kernel thickness and specific density. Size of starch granules and proportion for different type starch granules also varied with different wheat kernel thickness and specific density. Those microstructure properties of the fractured surface, formation of endosperm cells, protein matrix and starch granules were close related to rheological properties and pasting properties of wheat grains.
This study investigated the effects of three processing factors, acid blanching, centrifugation and dynamic high pressure homogenization, on cloud stability of carrot juice. Results indicated that the optimum processing condition for stabilized carrot juice were with dynamic high pressure homogenization at 100 MPa combined with 2% citric acid blanching at 95–100 ℃ for 2 min followed by 2000 r/min centrifugation for 10 min. The improvement of juice yield was also investigated using a pre-treatment of three commercial enzymes: Pectinex 3XL® (pectinase), Celluclast 1.5 L® (cellulase) and Novozyme 188™ (β-glucosidase). The combination of 0.1 g/kg of Pectinex 3XL®, 0.1 g/kg of Celluclast 1.5 L® and 0.1 g/kg of Novozyme 188™ at 50 ℃ and pH 4.0 for 90 min was the most effective condition to improve carrot juice yield from 49% to 67%. The enzymatic treatment increased juice total soluble solids from 7.5 to 8.9°Brix and β-carotene content from 21.4 to 33.7 mg/kg.
Mechanically separated chicken meat has become a common ingredient of comminuted sausage products, as ‘frankfurters’, mainly due to its low price. The present work aimed to develop a frankfurter from mechanically separated chicken meat surimi-like material, and evaluated the chemical, rheological, microbiological and sensorial properties of this product. The response surface methodology was utilized to investigate the effects of the soybean protein, potato starch and pig lard on the texture of the obtained frankfurters. For this purpose, five levels of each factor were evaluated: soybean protein varied from 0% to 6%, potato starch from 0% to 10% and pig lard from 2% to 12%. The regression analysis of the model showed that the soybean protein exerted a linear positive effect and a quadratic negative effect in the compression force of the product (p < 0.05), and that the variable which more influenced the shear force was the potato starch, presenting linear and quadratic effects (p < 0.05). The highest composite design averages obtained were 202.2 g for breaking force, 7.9 cm for deformation, 10.1 N for shear force, and 90.9 N.s for work of shearing. The obtained models presented high determination coefficients, explaining 97.31%, 97.83%, 97.49%, and 95.39% of the breaking force, deformation, shear force and work of shearing variabilities, respectively. The microbiological analysis demonstrated that the achieved results were below the limits fixed by the FDA. The mechanically separated chicken meat surimi-like material frankfurter presented 72.2% of acceptability and 59.3% of the examiners found the color of the product slightly lighter than the ideal. Finally, the frankfurter-type sausages, without pork fat, produced and characterized here have presented promising characteristics for commercial applications.
The polyphenolic fractions of fruits: Terminalia catappa, Carissa carandas, Ziziphus nummularia; spice oilseeds: thymol, mustard, fenugreek and poppy seeds; and herb: green and black teas were analyzed for their total phenolics, flavonoids and antimicrobial potential. All fractions from fruits, except anthocyanin of C. carandas, displayed substantial antibacterial activity in accordance to their phenolic contents, the difference in activity being quite significant (p < 0.05), highest for T. catappa (minimum inhibitory concentration, MIC: 7.8–1000 µg/mL) and lowest for C. carandas (MIC: 62.5–1000 µg/mL). With few exceptions, both green and black teas’ fractions inhibited the tested strains, however, green tea fractions (MIC: 15.63–125 µg/mL) were more active than black (MIC: 31.25–1000 µg/mL) and neutral were more active than their corresponding acidic fractions. Oil fractions of all oilseeds were found to be more active than their polyphenolic fractions, their antibacterial action decreased in the order thymol > mustard > fenugreek > poppy seeds (p < 0.05). Though the fruits used for the study are underutilized and have been emphasized for processed products, they may potentially be important to fight against pathogenic bacteria in view of their MICs. The teas and oilseeds, though a small part of total food intake, are more functional and active against the tested bacterial species and may find potential applications in therapeutics and food preservation.
Maceration and fermentation time and temperatures are important factors affecting wine quality. In this study different maceration times (3 and 6 days) and temperatures (15 °C and 25 °C) during production of red wine (Vitis vinifera L. Cabernet Sauvignon) were investigated. In all wines standard wine chemical parameters and some spesific parameters as total phenols, tartaric esters, total flavonols and colour parameters (CD, CI, T, dA%, %Y, %R, %B, CIELAB values) were determined. Sensory evaluation was performed by descriptive sensory analysis. The results demonstrated not only the importance of skin contact time and temperature during maceration but also the effects of transition temperatures (different maceration and fermentation temperatures) on wine quality as a whole. The results of sensory descriptive analyses revealed that the temperature significantly affected the aroma and flavour attributes of wines. The highest scores for ‘cassis’, ‘clove’, ‘fresh fruity’ and ‘rose’ characters were obtained in wines produced at low temperature (15 °C) of maceration (6 days) and fermantation.
The antimicrobial activity of essential oils extracted from a variety of aromatic plants, often used in the Portuguese gastronomy was studied in vitro by the agar diffusion method. The essential oils of thyme, oregano, rosemary, verbena, basil, peppermint, pennyroyal and mint were tested against Gram-positive (Listeria monocytogenes, Clostridium perfringens, Bacillus cereus, Staphylococcus aureus, Enterococcus faecium, Enterococcus faecalis, and Staphylococcus epidermidis) and Gram-negative strains (Salmonella enterica, Escherichia coli, and Pseudomonas aeruginosa). For most essential oils examined, S. aureus, was the most susceptible bacteria, while P. aeruginosa showed, in general, least susceptibility. Among the eight essential oils evaluated, thyme, oregano and pennyroyal oils showed the greatest antimicrobial activity, followed by rosemary, peppermint and verbena, while basil and mint showed the weakest antimicrobial activity. Most of the essential oils considered in this study exhibited a significant inhibitory effect. Thyme oil showed a promising inhibitory activity even at low concentration, thus revealing its potential as a natural preservative in food products against several causal agents of foodborne diseases and food spoilage. In general, the results demonstrate that, besides flavoring the food, the use of aromatic herbs in gastronomy can also contribute to a bacteriostatic effect against pathogens.
The effects of pre-harvest aminoethoxyvinylglycine treatments on fruit quality parameters and bioactive compounds of ‘Fortune’ plum during cold storage were investigated. Two different aminoethoxyvinylglycine doses were applied to plum trees two weeks prior to the estimated harvest date, and harvested fruit samples were kept in cold storage at 0 oC temperature and with 90 ± 5% relative humidity for 4 weeks. Lightness (L*) and hue angle values decreased in all treatments during cold storage. Weight loss (%) was significantly decreased (p < 0.05) with 100 mg/L-1 aminoethoxyvinylglycine treatment at the end of the storage. Fruit firmness at the end of the storage was significantly increased with aminoethoxyvinylglycine treatments. Total phenolics and total antioxidant activity were increased with aminoethoxyvinylglycine treatments till the 21st day of storage and decreased by the 28th day. Total phenolics and total antioxidant activity were significantly decreased (p < 0.05) with the 200 mg/L-1 aminoethoxyvinylglycine treatment at the end of storage. Rutin was significantly decreased with 100 mg/L-1 aminoethoxyvinylglycine treatment at the end of cold storage.
This work evaluated physicochemical parameters of Golden papaya stored under refrigeration in controlled atmospheres. The fruits were kept at 13 °C in chambers containing either 3 or 6% O2 combined with 6%, 10% or 15% CO2. Moreover, a normal atmosphere was produced with 20.8% O2 and 0.03% CO2 with ethylene scrubbing, and a control treatment was used with ambient conditions. Evaluations were performed at the following times: before storage, after 30 days of storage in controlled atmosphere, and after removal from controlled atmosphere and storage for 7 days in the cold room. At the lower O2 levels and higher CO2 levels, the ripening rate was decreased. The drop in pulp acidity was avoided after 30 days of storage at 3% O2, but the fruits reached normal acidity after removal from controlled atmosphere and storage for 7 days in the cold room. The reducing sugars remained at a higher concentration after 30 days under 3% O2 and 15% CO2 even 7 days after removal from controlled atmosphere and storage in the cold room. This atmosphere also preserved the content of ascorbic acid at a higher level.
The interaction between tea polyphenols (TPLs) and rice starch (RS) during gelatinization has been studied. In the RVA analysis, TPLs-fortified RS exhibited no clearly defined peak viscosity and hot paste viscosity. After excluding other factors, irregular viscosity changes were attributed to the strong interactions between RS and TPLs during pasting/gelatinization. Subsequently, the coupling constants of samples A (the gelatinized sample of the blend of 16% TPLs and RS) and B (the blend of 16% TPLs and gelatinized RS sample) in 1H-NMR measurements were found to be the difference. Sample A had two coupling constants, 26h J HH = 82.08, 100.77 Hz and 6h J HH = 35.57 Hz, whereas Sample B had one larger coupling constant, 9h J HH = 140.24 Hz. This implied that these two samples differed in H–H interaction and interaction strength of sample A may be stronger than that of sample B. More important is, sample A had clearly broadened O–H stretching and frequency red-shifts of C–O–H bending as compared with sample B in quantitative FT–IR analysis. The overall results indicate that TPLs and RS can have hydrogen bonding interaction during gelatinization.
Nitric oxide (NO) was applied to broccoli (Brassica oleracea L. var. italica) florets and analyzed its effect on chlorophyll degradation during postharvest senescence. Florets were treated with 1000 µL/L of NO for 5 h and placed in darkness at 20 °C. During storage, the NO treatment delayed yellowing and retarded the onset of chlorophyll degradation. The activity of lipoxygenase was not related to the development of yellowing during storage. However, the accumulation of malondialdehyde, which could be used as an index of lipid peroxidation, was higher in the control than observed in the NO treatment. In untreated broccoli florets during storage, lipid peroxidation influenced the yellowing of broccoli florets while NO-treated florets maintained chlorophyll levels and decreased lipid peroxidation.
Phenolic compounds play an important role in the defense system of the human organism against reactive oxygen species. They are present mainly in fruit and vegetables, but their bioavailability is the key factor determining their concentration in blood and tissues. The aim of this article was to study the transformations that apple polyphenols undergo during digestion. An in vitro model with dialysate membranes simulating the human alimentary tract was used for evaluating the composition and antioxidant properties of fresh apples and products of their digestion in dialysates. Epicatechin, chlorogenic acid, and procyanidins were the main antioxidant compounds in the whole fruits and flesh of the two varieties of apples analyzed. In the apple peel additionally quercetin glycosides were present. As a result of in vitro digestion both polyphenolic compounds concentration and the antioxidant activity of the dialysates increased as compared to the raw materials (from 35% to 95% and from 50% to 236%, respectively). In the simulated alimentary tract, it was proved that procyanidins disintegrate to (+)catechin, which is well absorbed from the small intestine, while chlorogenic acid and quercetin glycosides were characterized by a low bioavailability.
Sesame seeds must be dehulled before processing for the food industry because the husk provides undesirable darker color and bitter taste. Currently, sesame seeds are mechanically peeled but this procedure requires high volume of water, which is a scarce resource in most of the countries where sesame is consumed by humans. In this study, several chemicals have been used in order to facilitate the peeling process and reduce the water requirement. The feasibility of using chemicals was evaluated by studying the color (instrumental and sensory) and the microstructure of seeds. Addition of both NaClO and H2O2 before the mechanical dehulling of sesame seeds will be the recommended treatments for combining the dehulling and whitening steps of the sesame processing. This recommendation is supported by the high values of the L* and dehulling percentage and the low values of the color coordinates a* and b*. Besides, the scanning electron microscopy proved that the NaClO treatment was able to remove the hulls without causing damage to the cotyledons.
Genotoxic and antigenotoxic activities against direct acting mutagen nifuroxazide, and indirect acting genotoxin aflatoxine B1 (AFB1) of extracts prepared from fruits of Pistacia lentiscus, were studied using the SOS chromotest with Escherichia coli PQ 37 as a tester organism. It was found that different extracts showed no genotoxicity when tested with E. coli PQ 37 strain either with or without microsomal extract. On the other hand, our results showed that ethyl acetate fraction and total oligomers flavonoids (TOF) extract obtained from P. lentiscus significantly decreased the genotoxicicity induced by AFB1 (10 µg/assay) and nifuroxazide (20 µg/assay). In addition to antigenotoxic activity, these extracts showed an important free radical scavenging activity towards the 2,2-diphenyl-2-picrylhydrazyl (DPPH) free radical and an important antioxidant activity using xanthine/xanthine oxidase system.